High Efficiency Short Circuit and Overload Protection Earthing Protection Input Side Earthing Protection Contact Side Input Voltage 40~150V/140~260V Output Voltage 110V/220V Output Voltage Stability 1~2% Wave Form Sine Wave SVC500VA SVC1000VA SVC2000VA SVC3000VA Nominal output voltage 40-110-220-230-240 Vac single-phase Frequency 48 -62 Hz Power (kVA) 0.5 1 2 3 Maximum output current at 230V (A) 2 4.2 9 13.6 Maximum output current at 110V (A) 4 8.7 18.2 27.2 Efficiency 0.98 Accuracy 3% Regulation speed (ms/V) 2 Accepted load variation 0 to 100% Load power factor Any Overload 1,5 IN x 5 sec Harmonic distortion <0.5% Dimension (mm) 180x215x194 230x230x200 230x230x300 230x230x300 Weight (kg) 8 9 11 15
The SVC 4 single-phase Electronic voltage stabilizer is able to adjust the output voltage within 3% of the rated voltage. The main features of the SVC Series electronic voltage motor control power supply are: Microprocessor full control Compact size High regulation speed High efficiency Insensitivity to load variations and power factor.
A LED panel provides information on: Mains input voltage exceeding regulation limits Mains frequency exceeding limit Load level Overload WHY USE STABILISERS? ELECTRONIC STABILISERS ELECTRONIC LINE CONDITIONERS Proper operation of most electric and The operating principle of an electronic An electronic line conditioner combines electronic equipment depends to a stabilizer is based on the regulation of an electronic stabilizer, an isolating large extent on the power supply the voltage through self-transformer transformer and high attenuation voltage that must be kept as steady sockets selected and connected to the EMI/RFI filters in a single unit. and as near to the nominal value as output via static switches. It provides maximum protection for possible. In many installations, the Regulation is determined by a specific installations susceptible to voltage mains power supply tends to fluctuate electronic control circuit. fluctuations, high frequency line noise for a number of reasons. So devices Advantages of using an electronic and power surges. Advantages of the that overcome and correct this problem stabilizer are: line conditioners are: are often used and the ideal solution is No harmonic distortion Isolation between the line a stabilizer. AROS produces a full range Insensitive to the type of load or and the load power factor Low weight/power ratio Insensitive to the type of load Protection against power surges High reliability or power factor High voltage regulation speed.
ELECTROMECHANICAL STABILISERS Electromechanical stabilizers are: High quality voltage Insensitive to the type of load or power factor Low weight/power ratio High stabilizing accuracy High reliability Wide range of power ratings for single-phase or three-phase voltage AROS Technical Data