1. Determine the value of the load resistor. A. R L = 5 k B. R L = 5.5 k C. R L = 6 k D. None of the above Answer: Option B Learn more problems on : Diode Applications Discuss about this problem : Discuss in Forum 2. In the operation of a half-wave rectifier with a capacitor-input filter, the ripple factor can be lowered by ________ the value of the filter capacitor or ________ the load resistors. A. decreasing, decreasing B. decreasing, increasing C. increasing, decreasing D. increasing, increasing Answer: Option D Learn more problems on : Diode Applications Discuss about this problem : Discuss in Forum 3. As the temperature increases, ________, V BE ________, and I CO ________ in value for every 10C. A. increases, decreases, doubles B. decreases, increases, remains the same C. decreases, increases, doubles D. increases, increases, triples Answer: Option A Learn more problems on : DC Biasing-BJTs Discuss about this problem : Discuss in Forum Marks : 0/20 Total number of questions : 20 Number of answered questions : 0 Number of unanswered questions : 20 Feedback Quality of the Test : Difficulty of the Test : Comments: Take an Another Random Test! Go to Online Test Page Go to Home Page 00:29:54 http://www.indiabix.com/online-test/electronic-devices-test/122 1 of 6 4/9/2014 1:38 AM 4. The ________ of the input signal is one of the first concerns in the sinusoidal ac analysis of transistor networks. A. period B. frequency C. magnitude D. None of the above Answer: Option C Learn more problems on : BJT Amplifiers Discuss about this problem : Discuss in Forum 5. Refer to the following curves. Calculate I D at V GS = 1 V. A. 8.167 mA B. 4.167 mA C. 6.167 mA D. 0.616 mA Answer: Option B Learn more problems on : FET Devices Discuss about this problem : Discuss in Forum 6. When plotting the transfer characteristics, choosing V GS = 0.5V P will result in a drain current level of ________ I DSS . A. 0 B. 0.25 C. 0.5 D. 1 Answer: Option B Learn more problems on : DC Biasing-FETs Discuss about this problem : Discuss in Forum 7. Refer to this Figure. If V in was increased in amplitude a little, the signal voltage at the source of Q 2 would 00:29:54 http://www.indiabix.com/online-test/electronic-devices-test/122 2 of 6 4/9/2014 1:38 AM A. increase. B. decrease. C. remain the same. D. distort. Answer: Option C Learn more problems on : FET Amplifiers Discuss about this problem : Discuss in Forum 8. The midrange open-loop gain of an op-amp is 135 dB. With negative feedback this gain is reduced to 72 dB. The closed-loop gain is A. 135 dB. B. 72 dB. C. 207 dB. D. 63 dB. Answer: Option B Learn more problems on : Operational Amplifiers Discuss about this problem : Discuss in Forum 9. The ratio of the unity-gain frequency to the cutoff frequency is numerically equal to the level of ________. A. CMRR B. common-mode gain C. closed-loop gain D. open-loop gain Answer: Option C Learn more problems on : Operational Amplifiers Discuss about this problem : Discuss in Forum 10. The output impedance of a voltage buffer is ________. A. very low B. low C. high D. very high Answer: Option B Learn more problems on : Op-Amp Applications Discuss about this problem : Discuss in Forum 11. ________ amplifiers have the highest overall efficiency. A. Class A B. Class B or AB C. Class C D. Class D 00:29:54 http://www.indiabix.com/online-test/electronic-devices-test/122 3 of 6 4/9/2014 1:38 AM Answer: Option D Learn more problems on : Power Amplifiers Discuss about this problem : Discuss in Forum 12. What is the total phase shift requirement, around the feedback loop, for a phase-shift oscillator? A. 90 B. 180 C. 270 D. 360 Answer: Option D Learn more problems on : Oscillator Circuits Discuss about this problem : Discuss in Forum 13. In the phase-shift oscillator, the gain of the amplifier stage must be ________. A. 0 B. less than 29 C. greater than 29 D. Answer: Option C Learn more problems on : Oscillator Circuits Discuss about this problem : Discuss in Forum 14. In which period is the capacitor filter discharged through the load in a full-wave rectifier? A. The time during the positive cycle B. The time during which the diodes are not conducting C. The time during which the diode(s) is (are) conducting D. The time during the negative cycle Answer: Option B Learn more problems on : Voltage Regulators Discuss about this problem : Discuss in Forum 15. Which of the following is (are) diodes? A. Schottky B. Varactor C. Tunnel D. All of the above Answer: Option D Learn more problems on : Two-Terminal Devices Discuss about this problem : Discuss in Forum 16. The current capability of power diodes can be increased by placing two or more of the diodes in ________, and the PIV rating can be increased by stacking the diodes in ________. A. parallel, parallel B. series, parallel 00:29:54 http://www.indiabix.com/online-test/electronic-devices-test/122 4 of 6 4/9/2014 1:38 AM C. parallel, series D. series, series Answer: Option C Learn more problems on : Two-Terminal Devices Discuss about this problem : Discuss in Forum 17. In a half-wave variable-resistance phase control operation, the control cannot be extended past a ________ phase displacement. A. 45 B. 90 C. 135 D. 180 Answer: Option B Learn more problems on : PNPN Discuss about this problem : Discuss in Forum 18. Refer to this figure. The value of DC = 100 and V IN = 8 V. Determine I C(sat) . A. 18 mA B. 7.92 mA C. 1.8 mA D. 8 A Answer: Option B Learn more problems on : Bipolar Junction Transistors Discuss about this problem : Discuss in Forum 19. The main purpose of an instrumentation amplifier is to amplify small signals riding on large common-mode voltages. A. True B. False Answer: Option A Learn more problems on : Special-Purpose Op-Amp Circuits Discuss about this problem : Discuss in Forum 20. OTA stands for operational transistor amplifier. A. True B. False Answer: Option B Learn more problems on : Special-Purpose Op-Amp Circuits Discuss about this problem : Discuss in Forum 00:29:54 http://www.indiabix.com/online-test/electronic-devices-test/122 5 of 6 4/9/2014 1:38 AM 2008-2014 by IndiaBIX Technologies. All Rights Reserved | Copyright | Terms of Use & Privacy Policy Contact us: info@indiabix.com Follow us on twitter! Bookmark to: Elbatech Srl HV Amplifier elbatech.it High Voltage Amplifier Piezo Moving Quartz Crystal Microbalance SPM AFM Visit Electronic Design electronicdesign.com for technical updates on power design and integration (more) Upload Resume@Naukri.com Taking the NPTE in 2014? 00:29:54 http://www.indiabix.com/online-test/electronic-devices-test/122 6 of 6 4/9/2014 1:38 AM