Professional Documents
Culture Documents
F4, fluid.
N8Per @2C$ G.6. .0,9
4.,. Tan! and Ca'inet 2nclosure
4.,.1. The hi)h-volta)e and lo%-volta)e compartments separated 'y a metal
'arrier shall 'e located side-'y-side on one side of the transformer tan!. Lhen
vie%ed from the front the lo%-volta)e compartment shall 'e on the ri)ht. 2ach
compartment shall have a door that is constructed so as to provide access to the
hi)h-volta)e compartment only after the door to the lo%-volta)e compartment has
'een opened. There shall 'e one or more additional fastenin) devices that must 'e
removed 'efore the hi)h-volta)e door can 'e opened. Lhere the lo%-volta)e
compartment door is of a flat panel desi)n the compartment door shall have three-
point latchin) %ith a handle provided for a loc!in) device. :in)e pins and associated
'arrels shall 'e constructed of corrosion-resistant material passivated #0S0 Type
,04 or the e5uivalent.
4.,... # recessed captive penta-head or he*-head 'olt that meets the dimensions per
#/S0 C5+.1...7 shall secure all access doors.
4.,.,. The compartment depth shall 'e in accordance %ith C5+.1..,4 unless additional
depth is specified.
4 of 14 B Cune .00= B /e% 0ssue
D.00= Cooper 0ndustries. #ll 4i)hts 4eserved.
Three-Phase Pad-mounted Compartmental Type G.10-1.-1
4.,.4. The tan! 'ase must 'e desi)ned to allo% s!iddin) or rollin) in any direction. 6iftin)
provisions shall consist of four liftin) lu)s %elded to the tan!.
4.,.5. The tan! shall 'e constructed to %ithstand + psi %ithout permanent deformation and
15 psi %ithout rupture. The tan! shall include a 15 psi) pressure relief valve %ith a
flo% rate of minimum ,5 SCF&.
4.,.A. The e*terior of the unit shall 'e painted &unsell +G<,..=11.5 )reen 8ST$9 #/S0 +0
)ray or #/S0 A1 )ray in color. 0f a special paint color is specified a federal spec
num'er or paint chip must 'e provided at the time of order. The ca'inet interior and
front plate shall 'e painted )ray for ease of vie%in) the inside compartment.
4.,.+. The tan! shall 'e complete %ith an anodiIed aluminum laser en)raved nameplate.
This nameplate shall meet /ameplate > per #/S0 C5+.1..00.
4.4. :i)h "olta)e >ushin)s and Terminals
4.4.1. :i)h volta)e 'ushin)s %ill 'e installed in the hi)h volta)e termination compartment
located on the front left of the transformer and re5uirin) access via the lo% volta)e
termination compartment on the front ri)ht.
4.4... >ushin) Style
5 6 15725 .# D8$DF%-9T! 4:%%89TS *8,-; 200 $MPS< The hi)h volta)e
'ushin)s shall 'e 151.5 !" .00# 'ushin) %ells %ith 'ushin) %ell inserts installed.
The 'ushin)s shall 'e e*ternally remova'le and 'e supplied %ith a remova'le
stud 84e; Cooper Po%er Systems catalo) sections 700-,. 500-1. and 500-.A9.
5 6 =5 .# D8$DF%-9T! 4:%%89TS *8,-; 200 $MPS< The hi)h volta)e 'ushin)
shall 'e a one-piece 150 !" .00-amp lar)e interface load-'rea! 'ushin) 84e;
Cooper Po%er Systems catalo) section 700-,=9.
5 6 157257=5 .# D8$DF%-9T! 4:%%89TS $*-#8 200 $MPS< The hi)h volta)e
'ushin) shall 'e a A00# dead-'rea! primary one-piece 'ushin) e*ternally
remova'le ,P rated inte)ral desi)n. #n optional =00 # 'ushin) is availa'le upon
re5uest 84e; Cooper Po%er Systems catalo) sections 700-45 and 700-4+9.
5 6 => .# T- 4> "# '250 .# *+,( D8$DF%-9T $PP,+4$T+-9S< The hi)h volta)e
'ushin) shall 'e a C@//2Q Plu)-in Ca'le Termination System siIe ,S. The
male and female portions of the 'ushin) shall 'e supplied %ith the transformer.
#vaila'le in radial feed only 84e; see %%%.pfisterer.com9.
5 6 157257=5 .# ,+#8F%-9T! 200 .# *+, M$?< The hi)h volta)e 'ushin) shall 'e a
porcelain 'ushin) %ith a t%o four or si*-hole spade or an eye'olt connector.
5 of 14 B Cune .00= B /e% 0ssue
D.00= Cooper 0ndustries. #ll 4i)hts 4eserved.
Three-Phase Pad-mounted Compartmental Type G.10-1.-1
4.4.,. >ushin) Confi)uration
5 6 15725 .# %$D+$, F88D D8$DF%-9T< The transformer shall 'e provided %ith
three 8,9 hi)h volta)e 'ushin)s in accordance %ith Fi)ure 1 dimensions 8Fi)ure
4a dimensions may 'e specified %hen a lar)er termination compartment for
)reater %or!in) space is desired9 from #/S0 C5+.1..,4 for radial feed
confi)urations. The 'ushin) hei)hts shall 'e in accordance %ith Fi)ure ,
dimensions 8Fi)ure A dimensions may 'e specified for )reater 'ushin) hei)ht9 of
#/S0 C5+.1..,4.
5 6 15725 .# ,--P F88D D8$DF%-9T< The transformer shall 'e provided %ith si*
8A9 hi)h volta)e 'ushin)s in accordance Fi)ure . dimensions 8Fi)ure 5a
dimensions may 'e specified %hen a lar)er termination compartment for )reater
%or!in) space is desired9 of #/S0 C5+.1..,4 for loop feed confi)urations. The
'ushin) hei)hts shall 'e in accordance %ith Fi)ure , minimum dimensions 8Fi)ure
A dimensions may 'e specified for )reater 'ushin) hei)ht9 of #/S0 C5+.1..,4.
5 6 =5 .# %$D+$, F88D D8$DF%-9T< The transformer shall 'e provided %ith
three 8,9 hi)h volta)e 'ushin)s in accordance %ith Fi)ure 4' dimensions of #/S0
C5+.1..,4 for radial feed confi)urations. The 'ushin) hei)hts shall 'e in
accordance %ith Fi)ure A dimensions of #/S0 C5+.1..,4.
5 6 =5 .# ,--P F88D D8$DF%-9T< The transformer shall 'e provided %ith si* 8A9
hi)h volta)e 'ushin)s in accordance %ith Fi)ure 5c dimensions of #/S0
C5+.1..,4 for loop feed confi)urations. The 'ushin) hei)hts shall 'e in
accordance %ith Fi)ure A dimensions of #/S0 C5+.1..,4.
5 6 4> .# 7 250 .# *+, D8$DF%-9T< The transformer shall 'e provided %ith ,
'ushin)s mounted 45R do%n from the horiIontal A0S from the )round and 1.S
apart from each other.
5 6 157257=5 .# ,+#8F%-9T! 150 .# *+, M$?< The transformer shall 'e provided
%ith three 8,9 'ushin)s in accordance %ith Fi)ure = of #/S0 C5+.1..,4 for radial
feed confi)urations. The 'ushin) hei)hts shall 'e in accordance %ith Fi)ure 10 of
#/S0 C5+.1..,4.
5 6 200 .# *+, ,+#8F%-9T< The transformer shall 'e provided %ith , 'ushin)s %ith
phase-to-phase and phase-to-)round clearances ade5uate for .00 !" >06.
A of 14 B Cune .00= B /e% 0ssue
D.00= Cooper 0ndustries. #ll 4i)hts 4eserved.
Three-Phase Pad-mounted Compartmental Type G.10-1.-1
4.5. 6o% "olta)e >ushin)s and Terminals
4.5.1. >ushin) Style
4.5.1.1. "olta)es less than +00 "olts; The transformer shall 'e provided %ith tin-plated
spade-type 'ushin)s for vertical ta!eoff. The spacin) of the connection holes
shall 'e 1.+5S on center per #/S0 C5+.1..,4 fi)ure 1,a. The 5uantity of
connection holes shall 'e 4 A 7 1. 1A or .0 holes.
4.5.1... Transformers ,00 !"# and 'elo% and 500 !"# %ith 470<1.++ secondary %ill
have t%o piece lo% volta)e 'ushin)s %ith studs and scre% on spades.
Transformers 500 !"# %ith .07<11.0 secondary and all transformers a'ove
500 !"# %ill have one-piece 'ushin)s.
Table =
Standard 7 Ma@imum *ushin& Aole Buantities
("# .07<11.0 470<1.++ and hi)her
45-,00 4 standard 1A ma*imum 4 standard 1A ma*imum
500 A standard 1. ma*imum 4 standard 1A ma*imum
+50-1500 1. standard .0 ma*imum A standard 1. ma*imum
.000-,+50 /1# 1. standard .0 ma*imum
84e; Cooper Po%er Systems catalo) sections 700-14 700-1A and 700-.19
4.5.1.,. >ushin) supports shall 'e provided for transformers re5uirin) 10 or more
connection holes. >ushin) supports shall 'e affi*ed to the ca'inet side%alls?
tan!-mounted supports mountin)s are not accepta'le.
4.5... >ushin) Confi)uration
The transformer shall 'e provided %ith 'ushin)s in a sta))ered arran)ement in
accordance %ith Fi)ure 11a dimensions 8Fi)ure 1.a dimensions may 'e specified
%hen a lar)er termination compartment for )reater %or!in) space is desired9 of #/S0
C5+.1..,4.
4.5.,. "olta)es )reater than +00 "olts; 4efer to section ,.1 for the 'ushin) type.
Secondary arran)ements shall 'e live-front or dead-front. $ead-front application
%ith a re5uired neutral shall have a porcelain Q0 'ushin). $ead-front application
may 'e loop feed %hen specified. Provide additional front 'arrier for hi)h volta)e
live front secondary creatin) an additional 'arrier after the lo% volta)e door has
'een opened.
+ of 14 B Cune .00= B /e% 0ssue
D.00= Cooper 0ndustries. #ll 4i)hts 4eserved.
Three-Phase Pad-mounted Compartmental Type G.10-1.-1
4.A. S%itchin)
5 6 Primar) S/itchin&< The primary s%itchin) scheme provided %ith the transformer
shall 'e one (only available option or radial eed) t%o or three on-off under-oil
load-'rea! s%itch8s9 or one four-position " or T-'lade load-'rea! sectionaliIin)
s%itch. 4efer to #ppendi* 1 for the schematics of these s%itchin) options 84e;
Cooper Po%er Systems catalo) sections 700-A4 and 700-A59.
5 6 Ma"e-before-brea" option for four-position! sectionaliCin& s/itch<
This s%itch option provides improved system relia'ility 'y eliminatin)
momentary interruptions durin) s%itchin) operations.
4.+. @vercurrent Protection
5 6 *$D---98T ;+TA *$4.-:P 4:%%89T ,+M+T+9G F:S8S< 8availa'le up to 1,0
amps of full-load transformer current up to ,4.5 !" )rounded %ye or ., !"
delta9. The hi)h-volta)e overcurrent protection scheme provided %ith the
transformer shall 'e an e*ternally remova'le load'rea! e*pulsion >ay-@-/et fuse
assem'ly %ith a flapper valve to minimiIe oil spilla)e. The 'ayonet fuses shall 'e
in series %ith 26SP under-oil partial-ran)e current-limitin) 'ac!-up fuses %ith an
interruptin) ratin) of 50000 #. 84e; Cooper Po%er Systems catalo) sections .40-
40 .40-45 .40-4A .40-4+ .40-47 .40-4= and .40-509
!or volta"es 2#000$ or %elta and above (&hich must also ta'e into account any
hi"her tap settin"s)( bayonet uses are not available.
5 6 4artrid&e fusin&! 32="#< Onder-oil cartrid)e fusin) shall 'e utiliIed
8availa'le up to .07 amps of full-load transformer current up to ,4.5!"
delta9. The hi)h-volta)e overcurrent protection scheme provided %ith
the transformer shall 'e under-oil cartrid)e fusin). Cartrid)e fuses
shall 'e in series %ith 26SP under-oil partial-ran)e current-limitin)
'ac!-up fuses %ith an interruptin) ratin) of 50000 #.
5 6 -ptional $ccessor)< #n interloc! shall 'e re5uired 'et%een the load-
'rea! s%itch scheme specified and the 'ayonet fuses such that the
fuses may not 'e removed unless the transformer has 'een de-
ener)iIed via the load-'rea! s%itch scheme.
5 6 M$G98?E +9T8%%:PT8%< 8availa'le up to 4. amps of full-load transformer
current up to ,5 (" )rounded %ye or 1+.1 (" delta9 The hi)h-volta)e
overcurrent protection scheme provided %ith the transformer shall 'e a three-
phase trip &a)ne*T 0nterrupter. This e*ternally resetta'le device may also 'e
used as an on-off s%itch. The three-phase &a)ne*T 0nterrupter shall 'e in series
%ith 26SP under-oil partial-ran)e current-limitin) 'ac!-up fuses %ith an
interruptin) ratin) of 50000 # 84e; Cooper Po%er Systems catalo) sections .40-
,, and .40-509.
7 of 14 B Cune .00= B /e% 0ssue
D.00= Cooper 0ndustries. #ll 4i)hts 4eserved.
Three-Phase Pad-mounted Compartmental Type G.10-1.-1
5 6 +9T8G%$, #$44::M! F$:,T +9T8%%:PT8% '#F+(< 8availa'le from 1, amps
up to =00 amps of full-load transformer current up to ,4.5 !" )rounded %ye or
delta ma*imum 150 (" >069 The hi)h-volta)e or lo%-volta)e overcurrent
protection scheme provided %ith the transformer shall 'e an inte)ral "acuum
Fault 0nterrupter 8"F09. The "F0 shall have a ma*imum interruptin) ratin) of
1.000# 4&S symmetrical 8optional 1A000 # 4&S symmetrical availa'le at 15
("9 %ith resetta'le fault protection up throu)h ,5!". The "F0 shall also include a
Tri-Phase electronic 'rea!er control %ith over 100 minimum trip settin)s and 5
selecta'le time current curves. The minimum trip settin) shall 'e QQ amps and
curve profile shall 'e the 2F (F TF F or : 84e; see Cooper Po%er Systems
'ulletins =+055 and 0.0,= and catalo) section S.75-+5-1 for the electronic
control9.
5 6 -ptional 8,SP $ccessor)< "F0 shall 'e in series %ith 26SP under-oil
partial-ran)e current-limitin) 'ac!-up fuses %ith an interruptin) ratin)
of 50000 #.
5 6 -ptional #F+ $ccessories< SC#$# 'oard? Ground fault detection?
&otor operator assem'ly? "isi'le 'rea! %indo%.
4.7. @vervolta)e Protection
4.7.1. The overvolta)e protection scheme provided %ith the transformer shall protect the
hi)h-volta)e or lo% volta)e %indin).
5 6 D8$D-F%-9T *:SA+9GS< 8ma*imum 150 !" >06 for volta)es up to 17 !" delta
and ,5 !" )rounded %ye9. 2*ternally mounted $istri'ution Class &.@.".2. $ead-
front el'o% arresters shall 'e supplied. 84e; Cooper Po%er Systems catalo)
section .,5-55 and .,5-A59 &.@.".2. arresters are for installation on .00 # rated
dead-front 'ushin) interfaces only. ) transormer bushin"s are rated 600 * or +00
*( ,---*. elbo& connectors( --/. )) elbo& connectors( or 600 * bushin"
adapters( each &ith a load-reducin" tap plu" or arrester connection( are re0uired
84e; Cooper .o&er 1ystems catalo" sections 2#5-22( 2#5-25( 2#5-52( 2#5-70(
2#5-71( 2#5-75( 2#5-++).
5 6 ,+#8F%-9T *:SA+9GS< 8up to .00 (" >069. 0ntermediate Class and $istri'ution
Class 8:eavy $uty &edium $uty 4iser Pole $uty9 arresters shall 'e supplied
'eneath the hi)h-volta)e 'ushin)s 84e; Cooper Po%er Systems catalo) sections
.,5-4. .,5-45 .,5-5. .,5-+0 .,5-+1 .,5-+59.
5 6 :9D8% -+,< 8for volta)es up to .+ !" delta and ,5 (" )rounded %ye9. 0nternally
mounted $istri'ution Class &@" under-oil sur)e arresters shall 'e supplied 84e;
Cooper Po%er Systems Catalo) Section .,5-=59.
= of 14 B Cune .00= B /e% 0ssue
D.00= Cooper 0ndustries. #ll 4i)hts 4eserved.
Three-Phase Pad-mounted Compartmental Type G.10-1.-1
5 6 -ptional $ccessor)< Three 8,9 disconnect s%itches shall 'e included
to disconnect the under-oil arresters from )round for transformer
testin) 84e; Cooper Po%er Systems catalo) section 700-519.
5.0 ,abelin&
5.1. # temporary 'ar code la'el shall 'e attached to the e*terior of the transformer in
accordance %ith #/S0 C5+.1..,4F
A.0 Finish Performance %eGuirements
A.1. The tan! coatin) shall meet all re5uirements in #/S0 C5+.1...7 includin);
Salt Spray
Crosshatch adhesion
:umidity
0mpact
@il resistance
Oltraviolet accelerated %eatherin)
#'rasion resistance 3 ta'er a'raser
A... The enclosure inte)rity of the tan! and ca'inet shall meet the re5uirements for tamper
resistance set forth in #/S0 C5+.1...7 includin) 'ut not limited to the pry test pull test
and %ire pro'e test.
+.0 Production Testin&
+.1. #ll units shall 'e tested for the follo%in);
/o-6oad 875C or .0C9 losses at rated current
Total 875C9 losses at rated current
Percent 0mpedance 875C9 at rated current
2*citation current 8100H volta)e9 test
Lindin) resistance measurement tests
4atio tests usin) all tap settin)s
Polarity and phase relation tests
0nduced potential tests
Full %ave and reduced %ave impulse test
+... &inimally transformers shall conform to efficiency levels for li5uid immersed distri'ution
transformers as specified in Ta'le 0.1 of the $epartment of 2ner)y rulin). U10 CF4 Part
4,1 2ner)y Conservation Pro)ram for Commercial 25uipment; $istri'ution Transformers
2ner)y Conservation Standards? Final 4ule? @cto'er 1. .00+.S &anufacturer shall
comply %ith the intent of all re)ulations set forth in noted rulin). This efficiency standard
does not apply to step-up transformers.
10 of 14 B Cune .00= B /e% 0ssue
D.00= Cooper 0ndustries. #ll 4i)hts 4eserved.
Three-Phase Pad-mounted Compartmental Type G.10-1.-1
+.,. 0n addition the manufacturer shall provide certification upon re5uest for all desi)n and
other tests listed in C5+.1..00 includin) verification that the desi)n has passed short
circuit criteria per #/S0 C5+.1..00 and C5+.1..=0.
+.4. 0n the event of proposal 'id evaluated %ith )uaranteed losses due to a loss evaluation
8see section 10.09 manufacturer shall conform to )uaranteed avera)e losses as
specified in #/S0 C5+.1..00. The no-load losses of a transformer shall not e*ceed the
specified no-load losses 'y more than 10H and the total losses of a transformer shall
not e*ceed the specified total losses 'y more than AH.
7.0 $ppro0ed Manufacturers
7.1. Cooper Po%er SystemsVLau!esha L0
=.0 $ccessories
=.1. The follo%in) accessories and options shall 'e provided;
5 6 >olted main tan! cover 81000 !"# W 'elo%9
5 6 Lelded main tan! cover %ith 'olted handhole 81500 !"# W a'ove9
5 6 1.0S upper fill plu)
5 6 1.0S drain plu) in 6" compartment 8500 !"# W 'elo%9
5 6 1.0S drain valve %1 samplin) device in 6" compartment 8+50 !"# W a'ove9
5 6 #utomatic pressure relief valve
5 6 &etal drip shield 8%hen 'ayonets specified9
5 6 .0S deep ca'inet 8.500 !"# W 'elo%9
5 6 .4S deep ca'inet 8,000 !"# W a'ove9
5 6 Ground provisions per C5+.1..,4 section =.11.
5 6 &eet /2&# T4-1 sound levels
5 6 6i5uid level )au)e
5 6 $ial-type thermometer )au)e
5 6 Pressure vacuum )au)e
5 6 1.0S drain valve %1 samplin) device in 86" or :"9 compartment 8500 !"# W 'elo%9
5 6 Opper fill valve
5 6 Pressure vacuum 'leeder
5 6 .4S deep ca'inet
5 6 ,0S deep ca'inet
5 6 ,AS deep ca'inet
5 6 40S deep ca'inet
5 6 Spare 'ayonet fuse lin!s
5 6 Fault indicator provisions
5 6 Ground connectors
5 6 &r. @uch %arnin) W dan)er si)ns
5 6 $an)er hi)h volta)e %arnin) si)ns
5 6 &iscellaneous stencilin)
5 6 /on-PC> decal
11 of 14 B Cune .00= B /e% 0ssue
D.00= Cooper 0ndustries. #ll 4i)hts 4eserved.
Three-Phase Pad-mounted Compartmental Type G.10-1.-1
5 6 Touch-up paint
5 6 0nterphase 'arriers 8for live front primary units only9
5 6 Seismic Ione , and 4 tan! anchorin)
5 6 Complete ,046 stainless steel tan! and ca'inet
5 6 ,046 stainless steel tan! 'ase and ca'inet sides W sill 8partial9
5 6 6i5uid level )au)e %ith au*iliary contacts
5 6 $ial-type thermometer )au)e %ith au*iliary contacts
5 6 Pressure vacuum )au)e %ith au*iliary contacts
5 6 Current or potential transformers
5 6 4apid rise relay %ith seal-in panel
5 6 Lindin) temperature indicator
5 6 Latt-hour meter pac!a)e 3 includes G2 !".c 2ncompass
T&
2lectronic &eter.
Factory supplied %irin) shall 'e internal to the ca'inet not in conduit.
Communication connection shall 'e the @PT@C@& port.
5 6 :armonic resistant (-factor desi)n (X4 = 1, or .0
5 6 Forced air @/#F 8mineral oil9 or (/#F 82nvirotemp F4,9 ratin). Forced air ratin)
re5uires documentation from Cooper Po%er Systems- customer that they are
a%are this transformer is no lon)er tamper resistant and is no lon)er in
compliance %ith #/S0 standards.
5 6 Future forced air ratin)
5 6 F& Glo'al 8F&9 #pproved transformer 8to comply %ith /2C 450-., listin)
restrictions for installations on near or inside of 'uildin)s9
5 6 Com'ination O6 6isted W Classified transformer 8to comply %ith /2C 450-.,
listin) restrictions for installations on near or inside of 'uildin)s9 per O6 QP6:
5 6 O6 6isted transformer 8certifyin) compliance %ith #/S0 standards only9 per O6
QP6:
10.0 -ptional Transformer 80aluation
5 6 /o unit evaluation 'ut include 5uote losses as reference only on 'id.
5 6 Onit loss evaluation )uaranteed avera)e losses. Criteria to properly evaluate
5uoted losses;
Core loss evaluation 8#-factor9 EEEE Y1%att
Lindin) loss evaluation 8>-factor9 EEEE Y1%att
8Cooper may 'e contacted for sample loss evaluation method9
11.0 Shippin&
11.1. Transformers 1000 !"# and 'elo% shall 'e palletiIed. Transformers 1500 !"# and
lar)er shall 'e loaded and unloaded %ith overhead cranes so a pallet is not to 'e
provided for these transformers.
1. of 14 B Cune .00= B /e% 0ssue
D.00= Cooper 0ndustries. #ll 4i)hts 4eserved.
Three-Phase Pad-mounted Compartmental Type G.10-1.-1
1..0 Data ;ith Proposal
1..1. The follo%in) data shall 'e su'mitted %ith the proposal;
Core losses 8%hen re5uested per Sections +.4 and 10.09.
Lindin) losses 8%hen re5uested per Sections +.4 and 10.09.
Percent 0mpedance
Typical 'id dra%in)
#pproval dra%in) 3 dra%in)s shall sho% final dimensions and features. Lhen
re5uested approval dra%in)s shall 'e provided per 5uoted leadtime.
4ecord $ra%in) 3 dra%in)s shall sho% final dimensions and features. Lhen
re5uested record dra%in)s shall 'e provided.
1,.0 Ser0ice
1,.1. The manufacturer of the transformer shall have re)ional service centers located %ithin .
hours fli)ht time of all conti)uous 47 states. Service personnel shall 'e factory trained in
commissionin) and routine service of 5uoted transformers.
1, of 14 B Cune .00= B /e% 0ssue
D.00= Cooper 0ndustries. #ll 4i)hts 4eserved.
Three-Phase Pad-mounted Compartmental Type G.10-1.-1
#PP2/$0Q 1; S%itchin) @ptions and Schematics
1 -n7-ff S/itch 2 -n7-ff S/itches = -n7-ff S/itches
84e; Cooper Po%er Systems catalo) section 700-A59
4-position sectionaliCin& s/itches;
#-blade s/itch
$escription of positions;
Feed from # W >
Feed from # only
Feed from > only
@pen V the loop is open and the transformer is de-ener)iIed
T-blade s/itch
$escription of positions;
Feed from # W >
Feed from # only
Feed from > only
@pen V the loop is closed and the transformer is de-ener)iIed
84e; Cooper Po%er Systems catalo) section 700-A49
14 of 14 B Cune .00= B /e% 0ssue
D.00= Cooper 0ndustries. #ll 4i)hts 4eserved.