You are on page 1of 66

UNLEASHING

THE COCONUT
POTENTIAL IN
KENYA






ABBREVIATIONS

ABD Agricultural Business Development

ASL Above Sea Level

ASPS Agricultural Sector Program Support

BDS Business Development Services

CBO Community Based Organisations

CSR Corporate Social Responsibility

DANIDA Danish International Development Agency

FAO Food and Agriculture Organization

FBO Faith Based Organisations

GDP Gross Domestic Product

ISO International Organization for Standardization

KARI Kenya Agricultural Research Institute

KCDA Kenya Coconut Development Authority

KEBS Kenya Bureau of Standards

KEPHIS Kenya Plant Health Inspectorate Services

KIRDI Kenya Industrial Research and Development Institute

KRA Kenya Revenue Authority

KES Kenya Shillings

NACADA National Authority for Campaign against Alcohol and Drug Abuse

NGO Non-governmental Organisation

ROSCA Rotating Savings and Credit Association

SACCO Savings and Credit Cooperative Society

VCO Virgin Coconut Oil
Introduction
The origins of the coconut palm scientifically known as Cocos nucifera can be traced to Malaysia,
Indonesia, Thailand, Vietnam and Philippines. It has since spread to most tropical and subtropical areas
through ocean currents and explorers and is currently found in over 50 countries mainly in Africa,
America and Asia. In Kenya it is almost exclusively found in the coastal regions even though other
regions are known to have varying potential for suitability of coconut farming.

The coconut palm (Cocos nucifera) is mostly found in the Kenyan coastal region due to the availability
of its specific agro-climatic requirements and the adoption of subsistence agricultural practices that
support coconut growing. However, it is highly adaptable to a variety of environments of up to 600m
(ASL) but limited in terms of commercial orientation in Kenya. Climatic conditions are a crucial factor
to be considered when establishing plantations in new regions that have previously not had coconut
because its productivity is highly dependent on agro ecological and climatic conditions. The agronomic
assessments conducted to identify other areas outside the coast that have potential to support coconut
production were classified as moderately suitable and marginally suitable. The moderately suitable area
is approximately 5,737.73 hectares and spans mainly from the Western Kenya regions of Butere
Mumias, Bungoma, Kakamega, Kericho, Kisumu, Nandi, Suba and Vihiga while the marginally
suitable area is approximately 157,636.446 hectares spread in various districts of the former Eastern,
Central, Rift valley, Nyanza and Western provinces.
These counties (Kwale, Mombasa, Kilifi, Taita Taveta, Tana River and Lamu) cover about 14% of the
countrys total landmass and host about 3.3 million people or 8% of the countrys population (Gok,
2010). Two of these counties (Tana River and Lamu) are classified as arid and three as semi-arid. The
primary policy challenge in coastal region is to ensure food and nutrition security in a sustainable
manner in environments that are prone to drought, where peoples access to and control over critical
livelihood resources such as land is insecure, and where climate change increases unpredictability.

The total number of coconut trees in the country stands at 9,907,115 on a total land size of 436,634
acres ( 176,699 Ha) which represents just a quarter of the land potentially available for coconut
growing. Kwale County holds the highest number of coconut trees with 4,714,157 trees followed
closely by Kilifi County with 4,192,983 trees. Other counties barely account for a tenth of the total
coconut tree population with 395 coconut trees are being planted on annual basis.

Coconut farmers in Kenya generally lag behind in husbandry and agronomic practices, adoption of new
farming technologies and consequently production. The crops potential is generally unexploited not
necessarily due to lack of attention by the farmers but mostly as a result of limited support by the
agencies that ought to provide technical information on good agricultural practices especially at the
production level. Poor yields are partly due to farmers lack of technical know-how on crucial
agronomic practices and limited adoption of technologies as demonstrated in this study. Coconut
farming in Kenya is also faced by the challenges of less than adequate rainfall, insect pests and lack of
clean quality seedlings.

The commercialization of coconut and coconut products has become important in Kenya due to the
exceptional role this crop is expected to play in increasing the sociaeconomics of the livelihoods at the
coastal region and other production areas. This role is in line with the countrys Vision 2030 and the
second Medium Term Plan (2013-2017) which includes the Agri-Business Development Programme. It
is envisioned that the commercialization of coconut production and processing will contribute towards,
job creation, especially for the youth and greater food security.

The subsector is mainly constrained by lack of a clear legal and institutional framework, very low
national research priority, poor funding situation, uncoordinated market actors, absence of value
addition, and general lack of prioritization. Currently Coconut contributes 1.5% of the agricultural GDP
or 0.4% of the national GDP (KES 12.6 billion) and has the potential to contribute KES 25 billion
annually

The coconut tree is recognized as an industrial crop in Kenya contributing over 1.5% of the agricultural
GDP and 0.4% of the national GDP. The sub-sector is estimated to support over 100,194 farmers and
provides income to many actors in the chain including seedling farmers, harvesters, de-huskers, wine
tappers, traders, transporters and processors among others. Although coconut is not one of the priority
value chains of Agricultural Sector Development Strategy (ASDS)

The coconut palm has multiple uses both as a cash and food crop noting that all parts of a coconut are
commercially exploitable. In addition, it creates numerous employment opportunities across the value
chain. The roots can be used for dye and medicinal purposes, the stem/trunk for timber used for fuel,
construction and furniture. Coconut inflorescence is used to produce toddy which when fermented is
used as an alcoholic drink. The fruit is used as food and is also processed into many products such as
copra, copra oil, virgin coconut oil, desiccated coconut, coconut milk, coconut cream and many more.

Six interrelated coconut value chains that require different interventions at different stages. These are:
1) whole coconut; 2) desiccated coconut, coconut water and related products; 3) coconut by-products;
4) coconut oil; 5) coconut (palm) wine and related products; and 6) coconut wood and leaves value
chains.

The total number of coconut trees in the country stand at 9,907,115 (2013 coconut survey report).
The trees are however concentrated in two counties. Kwale County has the highest population with
4,714,157 trees followed closely by Kilifi with 4,192,983 trees. Other counties barely account for a
tenth of the total population.

The value chain approach involves a consideration of all players involved from product conception to
consumption. According to Barnes, (2004) value chain is an alliance of enterprises collaborating
vertically to achieve a more rewarding position in the market. As in any system, the sum of the parts is
greater than the whole due to synergy. A value chain comprises of chain actors (involved in formation,
transformation and distribution of the product) and service providers and supporters who facilitate the
chain. Major value chain activities include input supply, production, transportation, processing and
marketing as well as eventual consumption.

The coconut value chain is complicated by the multiplicity of product value chains involved. In the
Kenyan case there is a general lack of industry statistics necessary for analysis. Despite being a key
cash crop in the coastal region the coconut hardly features in national statistics. This reports approach
considers generic agricultural value chain with broad categories of key players namely; input suppliers,
farmers, processors, traders and chain facilitators.


Value of Coconut Products
The coconut tree has many products both at the farm level and at the processing level. From the root to
the leaves there is no part of a coconut tree which cannot be commercially exploited. The main
products produced at the farm level include mature nuts, immature nuts, palm wine, coconut thatch,
brooms and coco wood. Some by-products of the nuts namely fibre and husks are also commercially
exploited by some farmers.

Some of the semi-processed products produced include desiccated coconut, copra, copra oil and coco
timber. These are processed both by farmers and in established factories. These products can be further
processed to yield other consumer products.
As the South Seas proverb goes He who plants a coconut tree, plants food and drink, vessels and
clothing, a habitation for himself and a heritage for his children
Fully processed coconut products in the Kenyan coconut industry include the following:
Virgin coconut oil (VCO), Coconut milk (cream and light), Bottled palm wine, Coconut vinegar,
Brooms, Shell charcoal, Coco-wood Furniture, Makuti, Coco-peat, Coir fibre and ropes, Door mats,
Body lotion and cream, Soap, Lamp shades and Artefacts.
9


Desiccated coconut, coconut water and related products value chain
This value chain consists of two key lines of products: fresh immature nut harvested for its tender
coconut water, and fresh mature coconut for desiccated, coconut cream, milk, powder, flakes and other
related products (Figure 6.4). All these are products are used as traditional fresh foods and drinks in
the local market.

Current Situation
The importance of tender coconut water has greatly increased and soon will surpass its normal
traditional demand. The coconut water has lately, albeit at a slow rate, found its way into formal
markets at the coast and has the potential to grow into a big soft drinks industry. The water is currently
being served in big tourist hotels as well as in local pubs and along the streets. To-date approximately
23.7 million nuts are used for the production of tender coconut water up from 18 million nuts in 2008.

Currently the prices of immature (green and tender) coconut are much higher than the prices of fresh
mature coconut. This difference is occasioned by the relatively higher farm costs of harvesting
immature coconuts. Supply of the immature coconuts is limited due to the high demand. Further, the
need for convenient drinking places and increased demand in urban centres and non-coconut growing
counties is creating a local niche market for processed and packaged coconut water. However, since
the tender coconut water is highly perishable, its quality quickly deteriorates with time. Thus there is
need for investments in pasteurization
5
and refrigeration as the market expands. At the moment no
pasteurization of tender coconut water is being in the country. There is also no well packaged or
refrigerated water for export.

Local production of the confectionery products has stagnated at about 9.2 tonnes annually. Kentaste,
located in Kaloleni is one of the local processors of desiccated coconut, coconut milk, Coconut water
flavour is very sensitive to heat, so ordinary pasteurization may not be applied without changing the
quality.
Cream and coconut shell powder.
House of Manji, one of the largest confectionery factories in the country, uses coconut products in most
of its products such as assorted delicious cream biscuits and chocolate coated biscuits. The company
imports nearly 15 tonnes of desiccated coconut per month from Far East. These are used in its Nairobi
and Kampala plants.

Most of the processed products of this value chain are imported. For instance, the country in 2012
imported 85,100 kg of desiccated coconut against exports amounting to 9,177 kg. The volumes of
imports and exports of coconut milk were 22,522 kg and 25 kg respectively (KCDA, 2013).

The current production of coconut water, flour, shredded, powder, milk, cream and desiccated coconut
products from fresh coconut will be scaled up from small production to medium and large production.
Most of the current home based processors, mainly dealing with simple coconut products such as
coconut milk, coconut water, coconut charcoal, shells and coconut cream, and medium scale processors
of products such as coconut milk, desiccated coconut, flour and powder will be capacitated to form
small cottage industries by 2016. This industrial process will involve medium and large scale
processing of these coconut products using highly hygienic methods that promote quality.
To support processing of coconut water, milk, coconut charcoal, shells and coconut cream, desiccated
coconut, flour, powder, etc., production of nuts will have to increase by a higher rate than that of
producing processed products. The expected increase in processed coconut will eventually create
higher producer prices which will in turn acts as an incentive for increased coconut production.

Table 6.2: Quantities (Kg) of Processed Products Expected to be Produced (2014-2018)

Coconut processed
products 2014 2015 2016 2017 2018

Coconut cream
1,617 2,021 4,042 6,063 8,084


Coconut cream powder
539 673 1,347 2,020 2,693


Coconut milk
4,510 5,638 11,276 16,914 22,552


Coconut milk powder
1,741 2,176 4,352 6,527 8,703


Desiccated coconut
17,020 21,275 42,550 63,825 85,100


Nata-de-coco
6,688 8,360 16,721 25,081 33,441


Source: Own Estimation
Figures of 2018 are the current import volumes (see KCDA, 2013)
Processing
Processing of coconut milk, coconut water, coconut charcoal, shells, coconut cream, coconut milk,
desiccated coconut, flour and powder will be scaled up to produce amounts indicated in Table 6.2.
Coconut de-huskers, de-shelling and sterilizers, dryers, coolers, boilers, grading and packaging
machines, etc. have to be accessed by processors. As most of these machineries have to be imported,
public-private partnerships will be crucial in capacitating the processors.

Marketing channels and distribution
Local, regional and export markets will be targeted for the sale of these products. Local markets will
include those at the Coast region, Rift valley, Eastern, Western, Nairobi and North Eastern regions. Te
expand the markets, export trade shows of these coconut products will be held in important trading
blocks such as USA and Canada, European Union and Sub-Saharan Africa, among others. Market
surveys will be done to provide market information on emerging markets. Sellers and consumers will
be informed on the availability of the products through market promotion campaigns.

Value chain enablement
Research on the nutritional contents and other aspects of the processed products will be done in order to
advise consumers accordingly. Higher yielding coconut varieties will also be introduced to farmers in
order to sustain increased production of processed milk, powder cream and other products. Educational
workshops to create awareness on nutritional value of processed products and availability of the same
in the market will be done. Standards of these coconut products will be developed and awareness
created among consumers and retailers in local, regional and international markets.

Value chain support
Credit services will be provided to ensure that actors have adequate funds to exploit coconut potential.
Other support services will include training of actors on production skills, processing and packaging of
the processed coconut products. These services will be availed to farmers by KCDA among other
institutions.

4.2.3 Mature Nuts
Production of mature nuts is done nearly by all farmers except those whose trees are yet to start
production. The mature nuts have both domestic and industrial uses. At the domestic level they are a
key ingredient in preparation of various dishes whereby the inner flesh is utilised. At industrial level
various products can be generated both from the flesh as well as the shell and the husks.
During 2012 it is estimated that a total of 246,416,329 pieces of mature coconuts were produced

There is a need for farmers to be mobilised into associations or cooperatives to ensure they sell directly
to processors thus bypassing the traders and middlemen. This would improve their bargaining capacity
resulting in higher prices. It should be noted that the percentage consumed at farm level may also
include semi-processing. The sales to consumers include direct sales at farm gate and also taking to
market.

In assessing the products it is important to look at an often neglected aspect of the value chain which is
the supply of inputs. The main input in coconut farming is seedlings.
In the past, farmers had a lot of challenges in accessing seedlings. Consequently KCDA initiated a
project to supply quality seedlings to farmers during the 2011/2012 season. This resulted in production
of 251,798 with a market value of 12,589,900 based on an average value of KES 50 per seedling.
However the nursery operators under the project were compensated at a rate of KES 30 per seedlings.
On average, research indicated that a total of 325,395 trees are being planted on annual basis. This
would translate to a value of KES 16,269,730 at an average of KES 50 per seedling. However some of
the seedlings planted are not transplanted due to lack of market.

Kwale County accounted for 45.26% of the total production while Kilifi County accounted for 47.5%.
On its part, Mombasa accounted for 2.82% while Lamu accounted for 2.79%. On the other hand Taita
Taveta accounted for 1.16% whereas Tana River accounted for 0.46% of the total output.

Despite Kilifi having more trees in the productive age bracket it contributes nearly the same as Kwale
County. This can be explained by wine tapping which is more prevalent in Kilifi than in Kwale. Most
of the tapped trees do not yield nuts.

Marketing Channels for Mature Nuts
Out of the total nuts produced 10.13% were consumed at the farm level, 60.9% were sold to traders,
23.22% were sold directly to consumers while 4.96% were sold to processors. A paltry 0.79% was sold
through cooperatives.

There is a need for farmers to be mobilised into associations or cooperatives to ensure they sell directly
to processors thus bypassing the traders and middlemen. This would improve their bargaining capacity
resulting in higher prices. It should be noted that the percentage consumed at farm level may also
include semi-processing. The sales to consumers include direct sales at farm gate and also taking to
market.

c) Estimated Value of Mature Nuts Produced in 2012
The estimated value of mature nuts produced stands at KES 2.7 billion. Kwale County contributed
45.6% of this value followed by Kilifi at 43.5%. Mombasa County accounted for 5.1% while Lamu
accounted for 3.8%. Taita Taveta and Tana River counties accounted for 1.5% and 0.5% respectively.

There is significant disparity in price across counties. There is also a wide price range from a low of
KES 3 to a high of KES 30. There is need for farmers to be assisted with market information on the
value of produce to protect them from exploitation. The high price reported in Mombasa may however
be attributed to proximity to a ready and large market in Mombasa town. Low price in areas of high
supply and high price in areas of low supply point to a need for deepening inter-county trade.

a) Estimated Volume of Immature/Tender Nuts Produced in 2012

4.2.4 I mmature/Tender Nuts

Tender coconut (7 to 8 months old maturity) is valued both for
its sweet water, which is a refreshing drink and the delicious
gelatinous meat (kernel), (Haseena, Bai and Padmanabhan,
2010). According to India Coconut

Board tender coconut water is the most nutritious wholesome
beverage that nature has provided for the people of the tropics
to fight the sultry heat.
11



In Kenya tender nuts commonly known as madafu are consumed mainly by the roadside where
vendors have stalls/stands, hawking where vendors approach buyers mostly in vehicles and in tourist
hotels where they are used as welcoming drink. The madafu are hardly sold in formal channels such
as restaurants.

These marketing patterns are driven by two factors. First the tender coconuts are highly perishable
with quality deteriorating within 24-36 hours of harvesting. According to Haseena, Bai and
Padmanabhan, (2010) it is seen that tender coconut cannot be stored for more than one week at room
temperature due to shrinkage and discoloration of skin, fall of perianth and fungal attack on the soft
perianth region.

The second factor influencing marketing of tender nuts is that they are bulky as they still contain
husks which limit their transportation. Nonetheless processing technology exists to increase the shelf
life of the product. The application of such technologies in Kenya is largely non-existent.
Consumption is limited to the Coastal areas and in parts of Nairobi mainly inhabited by Kenyans of
Asian descent mainly Westlands, Parklands and Ngara.

a) Estimated Volume of Immature/Tender Nuts Produced in 2012
It estimated that 24,775,202 pieces of immature coconuts were produced. These are distributed as
follows:

Kwale county accounts for 55.27% of the total volume of tender coconuts produced. Kilifi County
accounts for 26.55%, Mombasa follows with a contribution of 10.86% whereas Lamu contributes
5.01%. Tana River contributes 2.2% while Taita Taveta accounts for a paltry 0.1%. The interesting
point is that Mombasa accounts for 11% whereas it only accounts for 3% when it comes to production
of mature nuts. This can be attributed to large and easily accessible market in Mombasa town. This
makes transportation easy in view of bulkiness as well as making consumption fast in view of
perishability. The low contribution of Kilifi County while compared to Kwale can once again be
attributed to wine tapping which is more common in Kilifi.

b) Marketing Channels of Immature Nuts
The major outlet for immature nuts is through sales to traders who account for 45.22%. Residents own
consumption accounts for 25.82% while direct sales to consumers account for 28.66%.

The large percentage of sales to consumers and own consumption can be linked to earlier discussed
issues of perishability and bulkiness. No sales to processors or cooperatives were recorded. This can be
explained by the lack of value addition when it comes to processing and the high level of informality
when it comes to trading of immature nuts.

c) Estimated Value of Immature Nuts Produced in 2012
The estimated value of immature nuts is KES 260,971,955. Kwale County accounted for 47.22% of this
value while 30.25% is accounted for by Kilifi County. Mombasa County on the other hand accounts for
15.47% while Lamu accounts for 5.7% of the total value of tender nuts produced. At the tail end are
Tana River and Taita Taveta accounting for only 1.25% and 0.1% respectively.

County Pieces Average Price Value (KES) Percent Contribution
Produced (KES) to Total Value

Kwale 13,693,355 9 123,240,195 47.22%

Kilifi 6,578,782 12 78,945,384 30.25%

Mombasa 2,691,404 15 40,371,060 15.47%

Lamu 1,240,351 12 14,884,212 5.70%

Tana River 545,499 6 3,272,994 1.25%

Taita 25,811 10 258,110 0.10%
Taveta

Total 4,775,202 10.67 260,971,955 100.00%

With the average price of mature nuts at KES 13.7 and that of immature nuts at KES 10.67 the only
advantage to the farmers in selling immature nuts is that they do not have to wait for the coconuts to
fully mature. Prices are lowest in Tana River due to lack of established immature nuts trade. In
Mombasa the prices are high due to proximity to a ready market. The overall price range is a low of
KES 5 and a high of KES 30.

4.2.5 Palm Wine/Toddy
Coconut Toddy/Sap
Coconut toddy or sap is the sweet, oyster white and translucent liquid oozing from the unopened
coconut inflorescence when cut. When sweet toddy or fresh sap undergoes spontaneous fermentation it
produces a common alcoholic drink called `fermented toddy'. The toddy becomes stale when the
fermentation exceeds 24 hours. Normally, the toddy is consumed within 12 hours after the sap is
collected. The nutritional value of toddy for thiamine and riboflavin resides mainly in the yeast-free
fluid portion. Toddy also contains small amounts of protein, fat and other nutrients. Fermented toddy,
on distillation, yields a strong alcoholic drink known as Mnazi. The range of recovery is 15-18 per cent
of the original toddy. Normally, sweet toddy is allowed to undergo fermentation in loosely covered
wooden or plastic container for 3-5 days before it is distilled.
The coconut sap is a natural sweetener obtained by concentrating fresh coconut sap to a thick
consistency through careful boiling in open containers or vessels where it is allowed to cool and form
sugar crystals.

This is an alcoholic drink made by the fermentation of the sap
from a coconut palm. It is white and sweet with a characteristic
flavour. It is between 4 and 6% alcohol and has a shelf life of
about 24 hours. Toddy is harvested by cutting off a slice of tissue
from the tip of the spathe (the newly emerged but not yet open
sheath of the flower).The sap (or toddy) provides drink (sweet and
rich in vitamins when fresh; alcoholic after fermentation) and
sugar, (Foale, 2003).

Normally, the toddy is consumed within 12 hours after the sap is collected. The nutritional value of
toddy thiamine and riboflavin reside mainly in the yeast-free fluid portion. Toddy also contains small
amounts of protein, fat and other nutrients, (Gachanja, Musinga, Ngigi, Onyango and Bett, 2010).

In Kenya coconut wine is mainly consumed at the coast in drinking bars locally known as mangwes.
Consumption is limited outside the Coast due to the short shelf life. Some limited processing and
packaging is being done thus enabling it to be sold beyond the coastal region.


a) Estimated Volume of Palm Wine Produced in 2012
It is estimated that a total of 153,311,377 litres of palm wine were produced in 2012. This is shown in
the figure below;

Sources: Coconut Survey 2013

The leading county in production of palm wine is Kilifi contributing 76% to total production. It is
followed by Kwale County contributing 20%. Taita Taveta accounts for 2.7%, Mombasa accounts for
1.27% while Lamu and Tana River account for 0.37% and 0.11% respectively.
Counties inhabited largely by Muslims produce less due to religious beliefs which prohibit alcohol
consumption. This explains why despite Kwale and Kilifi having nearly the same number of trees Kilifi
produces more than thrice what Kwale produces.
b) Marketing Channels for Palm Wine

Findings indicate that 82.6% of the wine is sold through traders. Out of the balance 13.73 % is sold
directly to consumers, 3.05% to processors and 0.62% is consumed at the farm level.

This is one product whereby the market is dominated by one channel which points to poor market
development. There is need to develop the market by diversifying the channel through value addition.
Packaging and prolonging the shelf-life should be immediate priorities. Distillation of the palm wine to
produce other high value alcoholic drinks should be promoted. Direct sales to consumers may point to
unlicensed operations.


c) Estimated Value of Palm Wine Produced in 2012
The estimated value of the palm wine is KES 7.2 billion. Kilifi County earns most of this money
accounting for 72.2% of the entire value. Kwale County follows with 23.08% while Taita Taveta
accounts for 2.64% and Mombasa 1.54%. Lamu and Tana River contribute little to the value accounting
for 0.44% and 0.10% respectively.

Despite the high average price it should be noted that high price disparities were noted. A high of KES.
100 per litre and a low of KES. 10 per litre were recorded. There is need to provide market information
for farmers on the prices of the produce.

It should be further noted that nearly half of the amount does not accrue to farmers as it is paid to the
wine tappers at an average of KES. 22 per litre. Considering the high percentage which is sold, wine is
the most commercialised of all the coconut products.

4.2.6 Cocowood/Coconut Wood

The coconut tree trunk is a source of high quality hardwood
which is used for construction, furniture making and
production of artifacts. According to research done on
Kenyan coconut wood, the characteristics and properties
obtained were comparable with those from other parts of
the world.

The density ranges from low to heavy density 0.248 0.852gcm-3. The bending strength, bending
stiffness and crushing strength also range from very weak to very strong due to the density variation
(Oduor and Githiomi, 2010). Thus coconut wood can be a good substitute for more common
hardwoods hence aiding in conservation.

The wood is used in making premium quality furniture. However not many are aware of the coconut
wood and its characteristics. Thus market awareness is necessary to ensure customers willingness to
pay the premium rates.

a) Volume of Cocowood Produced and Contribution to Production by Counties
Findings indicate that a total of 168,224 were cut in 2012. The distribution by counties is as shown
below.
These findings further show that Kwale County was the leading producer of Cocowood accounting for
57.6%. It was followed by Kilifi County which accounted for 31.01%, Mombasa at 5.46% and Lamu at
4.67%. Tana River and Taita Taveta counties made minimal contribution at 0.47% and 0.79%
respectively.

These findings may create an alarming impression that massive felling of coconut trees is going on in
Kwale when compared to Kilifi as both have nearly the same number of trees. This can however be
explained by the findings on age of trees which show that Kwale is leading in no. of trees aged 61 and
above which are 1,291,728 compared to Kilifi with 454,578 such trees. It is at this age that the trees
become senile and underproductive.

b) Marketing Channels for Cocowood
The marketing dynamics indicate interesting results which point to low commercial exploitation of the
coconut wood. According to Oduor and Githiomi (2010), efforts to promote the use of Cocowood in
Kenya started in early 2003 in an attempt at searching for alternative wood species which could be used
in the wood carving sub-sector.
Findings indicate that majority of the wood cut is sold to consumers i.e. 44.25% which is followed
closely by 43.81% which is utilized by the farmers. The remaining 11.94% is sold to traders. This is
shown in the figure below;

These findings reveal low commercial utilization. There is need to step-up the effort to promote the
commercial utilization to ensure farmers get value for the trees. Oduor and Githiomi (2010) highlighted
various challenges which may explain this situation. These include;
i. Selection of the senile coconut tree, splitting/sawing and grading for specific use not yet fully
understood by most players in the Kenyan market,

ii. High cost of seasoning (Kiln technology) and other operations on coconut wood

iii. Lack of know-how in coconut wood finishing and preservation technology

iv. Inadequate market acceptance of coconut wood products at premium prices

v. Low level of coconut tree replenishment in the country for sustainable harvesting and utilization
of the resource.
c) Estimated Value of Cocowood Produced in 2012
The Cocowood harvested in 2012 is valued at KES 188,670,295. As expected, Kwale contributes the
bulk of this accounting for 62.04% followed by Kilifi at 27.1% while Mombasa and Lamu each
contribute 4.87%. Taita Taveta contributes 0.71% while Tana River contributes 0.42%.
4.2.7 Makuti/ Coconut Thatch
Table 15: Estimated Value Cocowood Produced in 2012
Makuti are pieces of roofing material made from
coconut leaves. It is a very eco friendly or green
building material as it is made from leaves that are
naturally wilting on the palm tree and therefore
harvesting does not affect the parent plant in any way.
The individual pieces (or tiles) have to be weaved first,
(Makuti, 2013).




The Makuti are valued for aesthetic value and their ability to stay cool under the hot coastal weather.
The demand and value of Makuti has risen rapidly
over the last ten years. Long held as a cheap alternative to the expensive roofing materials, palm
branches commonly referred to as makuti are fast rising as a symbol of prestige and cultural attraction
in coast hotels, a phenomenon that has seen their prices on an unprecedented upward trajectory for the
last decade with even five star hotels and villas spending millions in makuti roofing, (Muinde, 2013).
There is already enough demand for the products of this value chain in the coastal region. However,
in efforts to expand sales, new and emerging markets in hot areas outside the Coast region will
explored for the sale of makuti. These areas include counties in Eastern, Nyanza, North Eastern
and Rift Valley provinces that experience hot weather conditions.
This rise in demand though positive has resulted in some undesirable activities. Some farmers now
harvest the leaves and dry them under the sun instead of waiting for them to fall off the trees. This
might affect the trees if not properly handled. It also results in poor quality.
The cutting down of senile coconut trees (cocowood) and harvesting of leaves (makuti) is expected to
increase annually by 5%. The cutting down of aged coconut trees will be done sustainably, through a
replacement program that emphasizes on replanting new coconuts once the old ones have been
harvested. Farmers will be educated on responsible cutting down of coconut trees and the best
harvesting methods.

a) Volume of Makuti Produced and Contribution to Production by Counties
It is estimated that a total of 131,926,990 pieces of Makuti were produced in 2012

Sources: Coconut Survey 2013

Figure 22: Graph of Estimated Production of Makuti in 2012
Kilifi County led in production accounting for a whopping 69.74% of the total production. It was
followed by Kwale County which contributed 23.59%. Lamu on its part contributed 4.84% whereas
Mombasa settled for 1.03%. Tana River County contributed the least with 0.8% whereas Taita Taveta
had nothing to offer. This is shown in the figure below;

b) Marketing Channels for Makuti
Out of the entire production 6.89% was consumed by the farmers, 38.33% was sold directly to final
consumers whereas 53.38% was sold to traders. The remaining 1.4% was sold through cooperatives.
This is shown in the figure below;

Sources: Coconut Survey 2013

Figure 24: Chart of Marketing Channels for Makuti

c) Estimated Value of Makuti Produced in 2012
The value of the Makuti produced is estimated at KES 1.7 billion. As expected, Kilifi contributed a
large share of this value at 68.52% followed a distant second by Kwale which weighed in with 23.18%.
Lamu was third with a contribution of 6.95% while Mombasa contributed 0.93%, Tana River 0.43%
whereas Taita Taveta contributed nothing.

4.2.8 Brooms

Coconut brooms are made from the leaves of a coconut tree. They are said
to be easy to use and have a long functional life. Many types of brooms can
be made from the coconut leaves. One can make brooms with a stick and
others without for instance.

a) Volume of Brooms Produced and Contribution to Production by Counties
It is estimated that a total of 5,800,179 brooms were made in 2012.

Sources: Coconut Survey 2013

One interesting point is that Gachanja, Odhiambo and Musila, (2007) reported the production of
brooms at 8,760,254 pieces while our findings reflect 5,800,179 pieces. The likely explanation is that
Makuti being also a product of coconut leaves are offering stiff competition to brooms. Both the
demand and value of Makuti is rising rapidly.

This view is also supported by the finding that while in 2006 Kilifi and Kwale produced nearly the
same volume of Makuti, Kilifi is now leading by a large margin. On the contrary Kilifi now trails
Kwale when it comes to production of the brooms.

Findings indicate that Kwale County contributed most to production of brooms with a share of
53.12%. It was followed closely by Kilifi with 39.91%. Lamu weighed in a distant third 3.5% whereas
Mombasa drew in 3.48%. Tana River and Taita Taveta counties didnt register any contribution. This
is shown in the figure below;

b) Marketing Channels for Brooms
There are three outlets for the produced brooms. Out of the total production 12.29 was consumed by
the producers, 39.4% was sold to traders whereas 48.31% was sold directly to consumers.

Figure 27: Chart of Marketing Channels for Brooms
The high percentage of brooms sold directly to consumers point to market inefficiency. There is need to improve the volume of sales
progressing through the formal channel where it is possible to stimulate more demand and get higher value.

c) Estimated Value of Brooms Produced in 2012
The estimated value of brooms produced stands at KES 119, 640, 071. Kilifi leads in contribution to this value with a share of 50.3% while
Kwale follows closely with a share of 43.78%. Lamu and Mombasa account for the balance at 3.39% and 2.53% respectively.
Sources: Coconut Survey 2013
It is interesting to note that Kilifi accounts for a higher percentage than Kwale despite Kwale leading in the volumes produced. This is because
higher prices were realised in Kilifi compared to Kwale.

4.2.9 Husks and Fibre
Most farmers are ignorant of the value addition capacity of the coconut husk. During the year 2011 the country imported coco-peat products
worth KES 94.7M for use mainly in the horticulture sector. This is product made from coconut husks. Only 7% of the farmers indicated selling
the husks. It should however be noted that some coconuts are exported with the husks on. Regarding value addition to the husks only 3.7% of the
farmers indicated producing fibre.
The coconut husk produces fibre which is used for making ropes, door mats and rugs. It also yields coco peat which has various agricultural uses
especially in horticulture. The shell produces charcoal, handicrafts and activated carbon. The leaves are used for making roofing materials and
brooms.

4.2.10 Processed Products
The processing aspect of the industry is highly fragmented, small in scale and abnormally informal when compared with other agricultural sub-
sectors. This is complicated further by the many number of products which can be made from the coconut tree. This makes traceability and
valuation of processed products difficult. In addition there are no statistics of volume of raw materials taken in and final output of the processed
products. KCDA should therefore prioritise and expedite the process of collecting monthly raw materials intake and finished goods output from
all licensed processors.

Some of the processors have closed shop albeit temporarily e.g. Mutpet, Deepan Manufacturers Ltd, Kokocepts and Msambweni Partners Self
Help Group. Some of the reasons given for closure include unavailability and high cost of raw materials. Some of the processors produce as per
order. The following tables the processors of some nut product and their capacity.

Coco Peat
This is 'coir pith' or 'coir dust' is produced as a by-product when coconut husks are processed for the
extraction of long fibre. Coco peat is the binding material that comes from the fibre fraction of the
coconut husk. Coco peat is a good form of material when used in seed raising and propagation mix. It is
proven that coco peat is a better media for growing commercial vegetable and flower seedlings
compared to peat moss. For instance, Kenyas coco peat carries water eight times its weight, thus
making it ideal as a growing medium. This guarantees a greater advantage over peat moss.

4.3 Summary of Products and Value
Below is a summary of estimated volume and value of coconut products produced in 2012.

Product Units Volume Value m(KES) Percent Contribution

Wine Litres 153,311,377 7,236,523,322 59.0%

Mature nuts Pieces 246,416,329 2,693,340,495 22.0%

Makuti Pieces 131,926,990 1,745,615,617 14.2%

Immature Pieces 24,775,202 260,971,955 2.1%
nuts

Tree trunks No. of Trees 168,224 188,670,295 1.5%

Brooms Pieces 5,800,179 119,640,071 1.0%

Seedlings No. of 325,395 16,269,730 0.1%
Seedlings

Total 12,261,031,484 100.0%

Source: 2013 Coconut Survey

Table 21: Estimated Volume and Value of Coconut Products Produced in 2012

Palm wine continues to provide a huge proportion of the sub-sector earning. There is need to increase
value addition of palm wine to ensure more gains are realised.
Tender Coconut Water
This is the liquid endosperm which occupies the large volume of space enclosed by the kernel inside the
fresh coconut fruit. Coconut water is a natural, fat-free, low calorie and nutritious thirst quencher and
energy drink packaged by nature itself. With very low total solid content, coconut water is a very
nutritious fluid which contains sugar, protein, vitamins and micro-minerals needed by the human body.
It is a good source of electrolytes such as potassium, sodium, magnesium, calcium and chloride and it
rehydrates the body and is a natural isotonic beverage because of its balanced electrolyte content. It is
claimed to be a natural contender in the sports drink market with its delicate aroma, taste, nutritional
and functional characteristics required in a sports drink. Water from tender young coconut (7 9 month
old) has been medically proven to dissolve kidney stones. By modifying its electrolyte content, it was
been successfully used in oral rehydration and treatment of diarrhea in young children.

Confectionery Product
The fresh coconut harvested for the flesh and milk is used to make the coconut cream, the flakes,
powder, and desiccates. These components are largely ingredients for the baking industry in Kenya.
KASHATAS, CAKES, ICE CREAM FLAVOURED ETC

Copra
Copra is the dried coconut kernel. The name copra is derived from the Malayan word Kopra for dried
coconut. Copra and the oil it contains are the principal products of the coconut tree. For years copra has
been the primary product common to all coconut growing countries of the world. Copra making
prevents the spoilage of fresh coconut meat by reducing its moisture content to a level safe for transport
or storage. It is produced by drying split coconut kernels in shell (husked or un-husked) in the sun, in
kiln dryers or a combination of both. The kernel is removed from the shell when it is partially dried or at
the end of the drying operation. CHICKEN FEED

Virgin Coconut Oil
This is the purest form of coconut oil that is water white in colour and contains natural Vitamin E and
has very low peroxide value and low free fatty acid content. Virgin coconut oil is suitable for human
consumption in its natural state immediately after extraction and filtration. Normally it solidifies at
temperatures of 22 degrees centigrade and below, and liquidifies at temperatures of 27 degrees
centigrade and above. This oil is obtained from the fresh and mature kernel of coconut by mechanical or
natural means with or without the application of heat which does not lead to alteration of the oil and its
properties. It is reputed as "mother of all oils" due to its many important uses.

Coir Fibre DOORMATS
Coir fibres are found between the husk and the outer shell of a coconut. The individual fibre cells are
narrow and hollow, with thick walls made of cellulose. They are pale when immature but later become
hardened and yellowed as a layer of lignin is deposited on their walls. There are two varieties of coir.
Brown coir is harvested from fully ripened coconuts. It is thick, strong and has high abrasion resistance.
It is typically used in mats, brushes and sacking. Mature brown coir fibres contain more lignin and less
cellulose than fibres such as flax and cotton and so are stronger but less flexible. They are made up of
small threads, each about 1 mm long and 10 to 20 micrometres in diameter. White coir fibres are
harvested from the coconuts before they are ripe. These fibres are white or light brown in colour and are
smoother and finer but also weaker. They are generally spun to make yarn that is used in mats or rope.
The coir fibre is relatively water-proof and is one of the few natural fibres resistant to damage by salt
water.

4.4 Current Economic Value of the Coconut Sub-Sector
The coconut industry contributes to the economy in diverse ways that include contribution to the GDP,
employment and livelihoods, mitigation of forex losses, and to the hospitality industry as discussed
hereunder.

4.4.1 Contribution to GDP
According to World Bank country statistics, Kenyan GDP in 2012 stood at KES 3.4 trillion while
agriculture GDP stood at KES 809.4 billion. It can thus be concluded that the coconut sub-sector
contributed 1.5% of the agricultural GDP and 0.4% of the national GDP. While these figures may
appear low, it should be noted that the industry faces challenges in managing statistics and therefore a
lot goes unaccounted for.

4.4.2 Contribution to Employment and Livelihoods
The number of farmers engaging in coconut production is estimated at 100,194. In addition the
subsector provides income to seedling farmers, harvesters, de-huskers and wine tappers. Up the value
chain, the subsector provides a livelihood to traders, transporters and processors.

4.4.3 Prevention of Forex Losses
The value of the production is estimated $144.2 million. Were these products to be imported the
countrys forex reserves would be negatively impacted.

4.4.4 Contribution to Hospitality and Tourism
The industry contributes through decorative value of live trees and Makuti which are widely used in
construction of tourism hotels. Madafu are also used as a welcoming drink for tourists within the
coastal region.

4.5 Import and Export of Coconut Products
This section analyses the data on import and export trade of coconut products. The year analysis data
is for the year 2011.

4.5.1 Value and Volumes of I mports
The imports for 2011 were as shown below. Products weighing a total of 8.1 million Kgs valued at
KES 825.1 million were imported.

Imports 2011


Product Weight in Kgs CiF Value in KES
Coco Peat 3,209,290.00 94,663,329

Coconut Cream 8,084.00 2,148,137

Coconut Cream Powder 2,693.00 1,733,457

Coconut Milk 22,552.00 2,658,785

Coconut Milk Powder 8,703.00 4,235,433

Coconut Oil 4,659,415.00 695,297,386

Coconuts 76,077.00 2,443,789

Cosmetics 2,728.00 374,255

Desiccated Coconut 85,100.00 18,919,492

Nata Decoco 33,441.00 2,606,956

Grand Total 8,108,083.00 825,081,019

Sources: Data by KRA Customs Department. Analysis by Author

Table 22: I mports of Coconut Products
in 2011

4.5.2 Contribution by Various Products to Value of Total I mports
The major products imported were coconut oil, coco peat and desiccated coconuts contributing
84.27%, 11.47% and 2.29% of the total value of imports respectively. This amounted to 98.03% of the
total imports with the balance of 1.97% being contributed by other products as shown in the figure
below;












Sources: Data by KRA Customs Department. (Analysis by Author)

Figure 28: Chart of Contribution by Products to Value of Total I mports in 2011
There is need to increase production of coconut oil and coco peat as there is a local market for the
products. Most of the coconut oil was crude oil which is a raw material in manufacture of beauty
products. Unfortunately most of the coconut husks from which coco peat is made are thrown away or
used as fuel by the farmers oblivious of their value. There is also a need to link the importing
companies with local producers to stem the loss of forex in importing products which can be
substituted by local production.

4.5.3 Origin of Imports
The key origins of coconut imports into the country were Indonesia accounting for 43.57%, followed
by Singapore at 41.83%, India at 6.05% and Sri Lanka at 5.5%. Together these countries accounted
for 97% of the imports with the balance coming from other countries as shown below;




















Sources: Data by KRA Customs Department. Analysis by Author

Figure 29: Contribution by Countries to Value of Total I mports in 2011

4.5.4 Exports
Kenyan coconut exports mainly comprise raw nuts. This has been a source of serious concerns with
some even arguing for a ban on raw nuts exports. However, this would be counterproductive without
an assured local market. It could lead to an oversupply in local market depressing prices leaving
farmers with no option but to abandon the trees like was the case with cashew nuts sometime back.

4.5.5 Value and Volumes of Exports
Products weighing a total of 8.6 million Kgs valued at KES 39.8 million were exported. It should be
known that there is a lot of cross border coconut trade between Kenya and Tanzania all of which may
not be captured in official statistics. Also the value of coconuts appears to be grossly understated at
KES 2.5 per kg. This is shown in the table below;



Exports 2011


Products Weight in Kgs CIF value in KES

Coconuts 8,426,271 21,532,504

Virgin Coconut Oil 18,976 6,070,995

Coco Peat 88,200 5,133,105

Coconut Oil 16,460 3,430,055

Desiccated Coconuts 9,177 3,038,012

Coconut Fibre 15,025 608,133

Coconut Milk 25 6,244

Grand Total 8,574,134 39,819,049

Sources: Data by KRA Customs Department. Analysis by Author

Table 23: Exports of Coconut Products in 2011

The high export of raw coconut is a threat to value addition to the coconuts. This is reflected by the
fact that the imports are dominated by value added coconut products. This results in low
commercialization of the sector, poor income to value chain actors, loss of employment creation
opportunities as well as forex losses. The overall impact of this is diminished contribution of the
coconut subsector to wealth creation and development in the Coastal region. While an export ban is
not recommended factors that limit processors capacity to add value need to addressed. Linkages
between farmers and processors also need to be strengthened.

4.5.6 Contribution by Various Products to Value of Total Exports
Key coconut products exported by Kenya are raw coconuts which in 2011 accounted for 54.08% of all
exports. The other products contribution to exports was as follows; Virgin Coconut Oil at 15.25%,
Coco Peat at 12.89%, Coconut Oil at 8.61%, Desiccated Coconut at 7.63%, Coconut Fibre at 1.53%
and Coconut Milk at 0.02%.
Sources: Data by KRA Customs Department. Analysis by Author

4.5.7 Destination of Exports
The key coconut exports destination in 2011 were Tanzania (57.2%), Uganda (14.91%), USA
(11.36%) and Yemen at (8.48%). These accounted for 92% with the balance going to other countries
as shown below;












Sources: Data by KRA Customs Department. Analysis by Author

Figure 31: Chart of Contribution by Country to Value of Total
Exports in 2011
4.5.8 Export Trends
The following analysis would have been more informative if it had captured a longer period
preferably 10 years. The available information however only allowed a comparison of a three
year trading period (2010 - 2012). In the limited observation there was an increasing trend from
2010 towards 2011 which dropped in 2012. It is not predictable how the future trends in this
segment will look like but this will depend a lot on what interventions the value chain
influencers will direct towards the sector.











Sources: Data by KRA Customs Department. Analysis by Author

Figure 32: Graph of Trends in Export over the Years

4.6 Key Industry Players in the Coconut Value Chain
An agricultural value chain comprises five key activities namely; input supply, production,
processing, trading and consumption. In addition to these are various support services providers.
The coconut value chain has the following key players along the value chain.

4.6.1 I nput Supply
The key inputs in the coconut value chain are seeds, seedlings, fertilizers, manure and water.
Higher up the value chain are suppliers of equipment, tools, machines and consumables used in
activities such as farming, wine tapping, harvesting and processing. The key players in input
supply in coconut value chain are;

4.6.2 Seed Nut Suppliers
The seed nut suppliers are farmers who allow the nuts to mature to a level where they can be
used as seeds. To ensure quality seeds KCDA engaged in an exercise which led to marking of
over 8,000 coconut trees with good production qualities, (Kahindi, 2012). This will ensure
quality seedlings with ultimate improvement in productivity. Seed nut suppliers play a critical
role in ensuring adequate and consistent supply of seeds for planting by the nursery operators.
4.6.3 Nursery Operators

They supply coconut seedlings to farmers. They play an
important role of ensuring adequate and quality seedlings are
available. They can also play a key role in introducing new
seedling varieties. KCDA has continued to invest in nursery
operators through supply of seeds, financing, extension and
training. In this regard more than 400 nursery operators have
been trained throughout the coastal region, (Kahindi, 2012).

4.6.4 Suppliers of Other Farming Inputs
These provide inputs such as chemicals and fertilizers. Most coconut farmers do not use these
inputs due to lack of awareness and financial constraints. They play a key role in stocking the
supplies and offering advice to farmers. They can also pass critical information to farmers e.g.
through distribution of farming pamphlets and brochures.

4.6.5 Suppliers of Non-farming I nputs
They provide tools, equipment, machinery and consumables. Players in this area include
fabricators of processing equipment, suppliers of labeling and packaging materials. They play a
key role in facilitating value addition to various coconut products.

4.6.6 Production of Primary Coconut Products

The key players here are farmers. It is estimated that
there are about 100,194 farmers spread across the
coastal region. The farmers are mainly small scale with
an average of 99 trees per farmer. The farmers play a
critical role in ensuring that upstream value chain
players such as traders and processors have consistent
supply of quality products. At the production level there
are other players who are important. They include;

4.6.7 Harvesters
The harvesters climb the tree and fell the tender or mature nuts. This is in a way a specialised skill
since not everyone can climb the trees. The harvesters are paid per nuts or per tree harvested.
Some of the harvesters are family members who offer the services for free.

4.6.8 De-huskers
They prepare the nuts for the market by removing the outer cover known as the husks. The de-
husked nuts are easier and cheaper to transport as they are less bulky. The de-huskers are paid
mostly on the basis of number of nuts de-husked rather than duration worked.

4.6.9 Wine Tappers
These are people with specialised skills in wine tapping. They climb the tree to tap the wine and
to collect the toddy which has settled on the bottle attached to the cut fluorescence. The payment
for wine tappers is usually in kind through various arrangements. In some cases the tappers share
the wine on a 50:50 basis or alternate days whereby the tapper takes one days harvest and the
farmer takes for the next days.

4.7 Trading of Coconut Products
The key players here are traders, farmer organisations, agents and logistic service providers.
4.7.1 Traders in the Coconut Value Chain
The traders play key roles which include;

i. Identification of location of produce

ii. Bulking of products they gather produce from various farmers for sorting, grading and
packaging

iii. Facilitating logistics e.g. transport, packaging and storage

iv. In coconut value chain, traders play a critical financing role as they pay the farmers upon
which point they take ownership of produce and all the risks thereafter. They also often
pay for harvesting and de-husking of coconuts.

v. Traders also provide feedback to farmers e.g. on quality of products and consumer
complaints or suggestions.

The traders include retailers, wholesalers/distributors, exporters and importers. There is also the
palm wine bar operators known as mangwes who sell the palm wine to final consumers.

4.7.2 Farmers/Producer Organisations
Some farmers and wine tappers are organised into associations or groups such as cooperatives.
The groups play a key role in bulking produce, looking for market and negotiating for good
prices for members. Such groups can also play key roles in value addition and provision of
financial services. In addition the groups make it easier for members to receive services such as
information, linkage, extension and training.

4.7.3 Agents/Middlemen
These are also known as brokers and they play key role of linking buyers and sellers. They are
hated by farmers who complain that they exploit them. Nonetheless the brokers play a key role
in managing information along the value chain.

4.7.4 Logistic Service Providers
They provide services such as transport, warehousing and packaging in distribution logistics.
Most farmers and traders do not own a means of transport and rely on external transport such as
PSVs, commercial distribution vehicles, human beings, bi-cycles, motorcycles, carts and animals
such as donkeys among others. They ensure the products reach the consumers at the right place, at
the right time and at the right condition.

4.7.5 Processing of Coconut Products
Key players here are the primary and secondary processors. They play a key role in value
addition. Where processors have contractual arrangement with producers, they can play a critical
role of providing, stable, reliable and favorable market. In the coconut sub-sector the primary
processors are mainly farmers or farmer groups who make products such as Makuti, brooms and
artifacts. Secondary processors engage in more advanced value addition by producing various nut,
timber and wine products.

4.7.6 Consumers of Coconut Products
Consumers are critical for without them there can be no industry. There are various ways in which
consumers of coconut products can be categorized. These include;

i. Domestic vs. international consumers

ii. Urban vs. rural consumers

iii. Coastal vs. up-country consumers

iv. Individuals vs. institutional consumers

v. Final consumers vs. industrial consumers
4.7.7 Value Chain Facilitators
These play a critical role of offering support services to various value chain actors. The key
players here are;
i. Government both national and county governments who offer various services such as
subsidized inputs and extension services
ii. Regulators ensure players abide by stipulated rules for the benefit of the industry. Key
regulators relevant to coconut subsector include KCDA, NACADA, KEPHIS, KEBS,
KRA e.t.c
iii. Research institutions create a knowledge base for various aspects of the chain from
production to consumption. In the coconut sector we have institutions such as KARI which
provide agricultural research services, Kenya Industrial Research and Development
Institute (KIRDI) which conducts research and development in all industrial and allied
technologies. Other research related institutions include universities and National Council
for Science and Technology.
iv. Non-governmental organizations these are mainly not for profit organizations which are
not owned or operated by government. In the coconut sectors there are many non-state
actors involved. These in addition to NGOs include Community Based Organizations
(CBOs) and Faith Based Organizations (FBOs). Such groups are involved in activities
such as advocacy and even value addition. Most of the processors in the coconut sector
have a non-profit orientation or background.
v. Trade facilitators are organizations which promote trade in the coconut products such as
Export Promotion Council.
vi. Business development service providers are private professionals offering advisory
services such as research, consultancy and training on various business aspects
vii. Financial institutions provide financial services to players along the value chains. They
include banks, SACCOs, ROSCAS, Microfinance Institutions, donors, government
devolved funds and private equity firms among others.

4.8 Challenges Facing Players in Coconut Subsector
This section looks at the challenges encountered along the value chain by various players.
Addressing these challenges will increase value chain efficiency and the subsectors gains.

4.8.1 Challenges Faced by Nursery Operators
Production Challenges Faced by Nursery Operators
Challenges were encountered by 90% of the operators. The major production challenges faced
are drought and lack of knowledge and skills each noted by 23.3% of the respondents. These are
followed by pests and diseases by 16.7%, theft of seedlings by 13.3%, low seed quality by
13.3% and inadequate supply of seeds also faced by 13.3% of the respondents. Other challenges
are faced by less than 10% of the respondents as shown in the figure below;














Figure 33: Graph of Production Challenges Facing Nursery Operators




Product Definition/Description Uses/Remarks
Coco peat Cocopeat (also known It is used as growth medium for
as cocos or coir) is the pithy high value crops. Its demand in
remnants of the coconut Kenya is rising.
husk after the extraction of Also used as an industrial absorbent
coir fibre.

Coconut milk This is the liquid that comes Used as ingredient in preparation of
from the grated meat/white various dishes
flesh of a coconut

Coir Fibre coir is the fibrous material Typically, white coir spun into yarn
found between the hard, is used in the manufacture of rope
internal shell and the outer and, thanks to its strong resistance
coat of a coconut to salt water, in fishing nets.
Brown coir is stronger and more
widely used than white coir.
Applications include sacking,
brushes, doormats, rugs, mattresses,
insulation panels and packaging

Copra This is the dried kernel or Coconut oil is extracted from it
meat of the coconut i.e. the The resulting residue called copra
white flesh inside the shell cake is used as livestock feed

Copra cake The residue of copra after Used as livestock feed
extraction of oil

Copra oil Oil extracted from copra Industrial uses e.g. biodiesel, engine
lubrication, transformer oil etc
Used for cooking
Cosmetic application and soap
manufacture

Desiccated Desiccated Coconut is a Desiccated Coconut is ideal for use
coconut grated, dried (3% moisture as fillers, toppings and as
content max.), and ingredients, especially in the baking
unsweetened fresh meat or of biscuits, snack bars, cakes,
kernel of a mature coconut. cookies and so on.

Nata de coco It is a chewy, Nata de coco is most commonly
translucent, jelly- sweetened as a candy or dessert,
like foodstuff produced by and can accompany many things
the fermentation of coconut including pickles, drinks, ice
water. cream, puddings and fruit mixes.

Virgin Coconut Coconut oil is an edible oil It has many applications in cooking
Oil extracted from the kernel or e.g. frying
meat of matured coconuts It has industrial application such as
harvested from the coconut lubrication and fuel
palm. It has various It has personal application where it
applications in food, can be used a moisturizer and is
medicine, and industry. used as an ingredient in soap and
hair products

Source: Compiled by authors from various online
sources






Product Raw Volume
Productio
n Volume Cost of Cost of
Manufacturin
g Total
Material of Units units e.g. of Units raw
Transpor
t costs Costs
Units of raw pieces, produced materials
e.g.
materia
l kgs, per
pieces, bought month
kgs,
litres

Coco
timber

Desiccate
d
coconut

Copra

Copra oil

Virgin
coconut
oil

Coconut
milk
(cream
and light)

Bottled



ARTIFACTS, LAMP SHADES, SOAPS BODY LOTION AND CREAM, DOOR MATS,
COIR FIBRE AND ROPES, COCOPEAT, MAKUTI, FURNITURE, WOOD, CHARCOAL,
SHELL, BROOMS, VINEGAR, PALM WINE, COCONUT




Product Volumesold Selling
Volum
e Selling Volume Selling
individuals e.g. price per Sold to Price Per exported Price Per
50kgs unit traders Unit Unit

Coco timber

Desiccated coconut

Copra

Copra oil


Virgin coconut oil (VCO)

Coconut milk (cream and
light)

Bottled palm wine

Coconut vinegar

Brooms

Shell charcoal

Coco-wood Furniture

Makuti

Coco-peat

Coir fibre and ropes

Door mats

Body lotion and cream

Soap

Lamp shades

Artefact

Total

Product Units of Volume of Buying Cost of Other direct costs
Trade e.g. Units traded Cost per transport e.g. storage,
pieces, per month unit packaging,
preparation

Immature nuts

Mature nuts

Toddy (palm wine)

Husks

Fibre

Wood

pieces, per month unit packaging,
preparation

Makuti

Desiccated coconut

Copra

Copra oil

Coco timber

Desiccated coconut

Copra

Copra oil

Virgin coconut oil

Coconut milk (cream
and light)

Bottled palm wine

Coconut
vinegar

Brooms

Shell charcoal

Coco-wood Furniture

Makuti

Coco-peat

Coir fibre and ropes

Door mats

Body lotion and cream

Soap

Lamp shades

Artifact

Total



15. What sales channels do you use and what prices are realised through each channel?

Product units sold Unit Units Unit units Sold Unit Units Unit
to Price sold to Price to Price
Exporte
d Price
individuals other processors
traders

Immature nuts

Mature nuts

Toddy (palm wine)

Husks

Fibre

Wood

Makuti

Desiccated coconut

Copra

Copra oil

Coco timber

Desiccated coconut

Copra


1. Whole nut
The fresh mature coconut is sold as a whole nut in both local and export markets. Instead of
processing the whole nut, actors (mainly local farmers and traders) in this value chain sell it direct
to consumers. At the coastal strip of Kenya fresh mature coconut has been used for food for
decades. The fresh mature coconut is sometimes de-husked and sold to vendors who then take it
to the market. Notably, once the whole coconut (could be mature or immature) is sold it is can be
re-directed to other value chains to produce oil, desiccated coconut, by-products, etc.

Thus, in some cases it is difficult to separate this shortest value chain from the processing value
chains.
Mature nuts are a key ingredient in preparation of various home dishes whereby the inner flesh is
utilized. Kwale and Kilifi counties dominate the production of mature coconuts with 46% and
44% of the total respectively, while about 10% comes from all other counties. Over 60% of all
mature nuts are sold to traders who then supply coconut processing factories.

2. Desiccated coconut, coconut water and related products
Tender coconuts known as madafu are harvested at 7 to 8 months maturity and are valued for their
sweet water and gelatinous kernel. They are used fresh immediately after harvest by cutting off
the edge of the nut and drinking the sweet water with a straw. The madafu have a short shelf life
and start deteriorating within 24 to 26 hours after harvest, so they tend to be consumed close to
their place of production. Kwale, Kilifi, Mombasa and Taita counties are the largest producers of
madafu and respectively account for 55%, 27%, 11% and 5% of all the madafu produced in
Kenya.
Simple processing technologies exist to convert the coconut kernel into products that can be
consumed by the families of coconut farmers or sold into the domestic market to increase
farmers income. These products include coconut water, coconut milk, cream, powder, and flour,
and desiccated coconuts.
Coconut water occupies the center of the coconut kernel. It contains sugar, dietary fiber, proteins,
antioxidants, vitamins, and minerals, and provides an isotonic electrolyte balance. It is consumed
as a refreshing drink throughout the humid tropics, and is gaining popularity as a sport drink.
Mature fruits have significantly less liquid than young, immature coconuts, barring spoilage.
Coconut water can be fermented to produce coconut vinegar.
Coconut milk is obtained primarily by pressing the grated coconut's white kernel or by passing
hot water or milk through grated coconut, which extracts the oil and aromatic compounds. It has a
fat content around 17%. When refrigerated and left to set, coconut cream will rise to the top and
separate from the milk. Coconut milk can be further processed by fermentation into Nata-de-
coco, a white, gelatinous and chewy product that can be sweetened by boiling in a sugar solution.
Coconut milk is also used to produce virgin coconut oil.

3. Coconut oil
The most commercially important product of coconut is the oil obtained from its kernel. Coconut
oil contributes nearly 7% of the total vegetable oils traded in the world. The volume of coconut oil
produced in the world in 2013 was estimated at over 3.5 million metric tons, with the Philippines
(1.725m), Indonesia (0.974m) and India (0.447m) being the three largest producers.

Coconut oil is extracted from the dried coconut kernel (copra) using mechanical expellers or
solvent extraction. After extraction, the oil is unsuitable for human consumption and must be
refined, bleached and deodorized, hence its designation in general trade as RBD coconut oil.
Although there is no industry standard definition of Virgin Coconut Oil (VCO), it can only be
obtained from fresh coconut kernel using a quick drying method or through a wet milling process.
Traditionally, the wet milling process has been used to produce a VCO of very high quality
because of the high level of antioxidants that it contains.

4. Coconut by-products
The processing of coconut to produce coconut water, coconut milk, copra and coconut oil
generates by-products that can be converted into other products that have great commercial value.
These by-products are the husks, the kernel shells and the coconut kernel cake.
Coconut husks are rich in fiber known as coir and are the raw material for the coir industry; they
are used in ropes, mats, door mats, brushes, sacks, caulking for boats, and as stuffing fiber for
mattresses. They can find a valuable use in potting mix (known as coco peat) for the horticultural
industry. Through incomplete burning, coconut husks and shells can be converted to charcoal
briquettes or activated carbon of high quality for the removal of impurities. Coconut shells are a
The cake resulting from the extraction of oil is known as coconut kernel cake or copra meal. It is a
good ingredient in dairy rations as a source of energy and protein, but its high fiber content makes
it unsuitable for monogastric animals. A 10% inclusion rate or 1.5-2 kg/d is recommended as the
maximum safe level for cows.

5. Coconut (palm) wine and related products
When an incision is made in the flower clusters of the coconut, a sweet sap (sugar content up to
16%), also known as toddy, is obtained. When left to ferment on its own, it becomes coconut
wine, which can be distilled to produce a strong alcoholic drink.

Boiling the sap produces a sweet syrup or candy that can be processed further to yield coconut
sugar also referred to as palm sugar. A well-maintained tree can produce around 300-400 liters of
toddy per year.

6. Coconut wood and leaves
The stiff mid-ribs of coconut leaves are used for making brooms. The leaves also provide material
for woven baskets and for roofing thatch; they can also be woven into mats. Coconut trunks are
used for building small bridges, huts and even houses; they are preferred for their straightness,
strength, and salt resistance, and are increasingly being used as an ecologically sound substitute
for endangered hardwoods.

6.3 Contribution of Different Coconut Value Chains to the Sub-sector GDP
The average contribution of different value chains to coconut production, export and import
monetary values is used as a proxy to their contribution to the subsector GDP (Table 6.1). Thus it
is assumed that production, export and import activities contribute equal shares to the subsector
GDP, though, as expected production is likely have a higher share due to the relatively higher
contribution to rural employment and support to manufacturing activities in the country.
Following this assumption coconut oil value chain emerges as the main contributor to subsector
GDP (36.1%), followed by whole coconuts (25.5%), palm wine and related products (19.7%) and
by-products (8.6%). The latter comprises one of the major value chains in terms of imports (only
second to coconut oil value chain) and exports (only after whole coconut and coconut value
chains). The by-products considered here are mainly processed into coco peat and other composts,
animal feeds and handicrafts. Most of them are sold mainly to flower producers, construction
industry, livestock farmers and tourists.

Table 6.1: Percent Contribution of Different Value Chains to Coconut Subsector GDP

Value chain % domestic % export % import value Assumed %
production value contribution
value to subsector
GDP
1. Whole coconut 22.1 54.1

0.3
25.5


2. Desiccated coconut,
coconut water and 2.1 7.6 3.9 4.5
related products
3. Coconut by-products NA** 14.4

11.5
8.6


4. Coconut oil NA 23.9

84.3
36.1


5. Coconut (palm) wine
59 NA

NA
19.7
and related products


6. Coconut wood and
16.8 NA

NA 5.6

leaves


Total 100.0 100.0

100.0
100.0


Source: adapted from KCDA, 2013 NA = data not available

**In estimating the average percentages in the last column the missing values are assumed to be
zeros

With the exception of the whole nut and desiccated coconut, coconut water and related
products, the percentage contribution of each value chain to the subsector GDP is used as the
criterion for apportioning the Master Plan budget. For instance, the coconut oil value chain is
allocated the 36.1% of the total Master Plan budget. For the budget allocation to the whole nut
and desiccated coconut, coconut water and related products value chains, it was considered that
most of the whole nuts sold in the market eventually end up being processed into other
products. Moreover, this Master Plan places more emphasis on value addition than sale of
whole nuts. Thus it was considered appropriate to exchange proportions of budget allocations
of these two value chains.
This consideration resulted in whole nut and desiccated coconut, coconut water and related
products value chains being allocated 4.5% and 25.5% of the Master Plan budget respectively.

6.4 The Role of Indirect Actors
The indirect actors considered in the Master Plan are divided into value chain enablers (e.g.,
government and its research and extension departments) and value chain supporters (finance
institutions, agro-dealers, farm implement suppliers, machinery suppliers, etc.) that contribute to
the successful flow of product through the different value chains. These play a critical role in the
successful functioning of the value chains. In addition to providing farmers with key inputs such
as new seeds and seedlings, extension services, human capacity services, etc., government and its
related institutions also establishes, monitors, and enforces rules, regulations, and policies
regarding quality standards. Credit institutions and some NGOs also provide some of the much
needed capital to farmers, traders and processors in these value chains. Similarly, the agro-dealers,
and other input/machinery suppliers are important linkages to the value chain actors and cannot be
ignored when promoting the sub-sector.

6.5 Current and Expected Situations of the Value Chains
6.5.1 Whole nut value chain
Current situation
The prices of the whole nut in the country have been low (average of KES 13.7 per kg) and
mainly depend on the seasonality of the crop. About ten years ago when the interest in the
industry was at its lowest, farms were virtually abandoned and a kilogram of coconut fetched less
than KES 6. This however changed with the entry of the Tanzanian traders and the formation of
KCDA. The Tanzanians have made the prices to move from KES 6 to KES 16 per kilogram
(Figure 6.3). Most Kenyans however do not consume the whole nut and therefore local prices are
lower than export prices. Although most of the whole nut is latter processed into other products,
focus is placed on selling of the whole nuts only as value addition and by-products have been
identified as different specific value chains. Thus this is the shortest coconut value chain in the
subsector.

Currently, this value chain earns the highest income for farmers. In 2012, about 3.39 billion nuts
were sold, earning farmers and traders approximately KES 2.9 billon. For the country whole nut
has also been the leading subsector export commodity in terms of value, accounting for over 54%
of all coconut exports. About 61% of the nuts are sold to traders who probably later channel them
to the processing value chains.

Figure 6.3: Whole Coconut Value Chain



The Coconut Farmer



By-products
Mature Fresh / Whole

16

Fresh Mature Coconut Trader


20

Local Market for
Fresh Export Market for Fresh
Value
addition
and
processing

Mature Coconut Mature Coconut


30 40

Consumers of Fresh Mature Coconut



---------------- Not part of the
chain Numbers represent prices
in KES/kg Source: own
presentation
Expected Situation

Production
Although coconut production for this value chain is projected to increase by 5% annually, this
Master plan will endeavor to maintain the current sales of fresh coconuts as extra nuts will be
channeled to value addition chains. Thus the percentage contribution to exports and subsector
GDP of this value chain is likely to decrease as investments in coconut processing increase. All
imports of whole nut will be eliminated by 2018 as there will be enough fresh coconuts in the
country.

Marketing and distribution of whole nuts
With increased coconut production, more local, regional and international markets will be
explored. The expanding East Africa Community market where members are allowed to trade
freely across the boundaries will be exploited. Expansion of international markets will target UAE
and USA among other countries.

Value chain Enablement
Research on new coconut varieties and particularly hybrids will be up-scaled in order to increase
the fresh coconut production. New high yielding, early maturing and drought resistant coconut
tree varieties are expected to be introduced to farmers in major coconut growing areas. More
coconut seedlings will be grown and nursery operators increased. Farmer cooperatives will be
established in order to increase the bargaining power of producers at the marketing stage. Farmer
demonstration plots will be introduced to exhibit possible agronomic practices that farmers need
to undertake to increase coconut yields. Some of the organizations that will help farmers and
traders are KCDA, KALRO and county governments.

Value chain support
Coconut producers and traders will be made to access more funding from banks and credit
institutions. These funds will be used to enhance fertilizer application and increase number of
nursery operators, and support agronomic activities. Coconut development fund will also be
established to avail more funds to farmers and coconut traders.

6.4.3 Coconut oil
Copra is very easy to process at the cottage level. It is currently being processed by farmers and
sold directly as copra oil. However, local prices are low due to the poor quality. Currently the
price of copra at the farm level is about KES 40/kg (Figure 6.5). To many farmers, it makes more
business sense to sell the dry nut even at the lowest price of KES 8/kg. Despite these challenges,
in some instances, traders amalgamate their coconuts and crush them into copra and sell direct to
the millers. About 8 main industries that used to deal in copra before 2006 have closed down and
those in operation are now largely dependent on imported palm oil from Malaysia. Some also buy
dry nuts and produce copra at the factory level. Some of the companies still processing Copra oil,
but at a small scale, are Amua, Serendi, Kentaste, and Malindi Industries.

The process of making virgin coconut oil (VCO) demands that the source of raw coconut is
carefully controlled. This is done in order to have the finished product comply with the strict
international standards that favor organically produced nuts. The nuts selected for virgin oil
production fetch higher farm gate prices than those sold for other uses. Currently, a number of
firms are making their entry into processing VCO and are heavily engaged in contracting farmers
who have to meet certain agronomical standards.

The oil produced is sold directly to end users and other manufacturers who use it as raw materials
for cosmetics, cooking oil, soap, pharmaceuticals and other products. At the moment there are just
a handful of virgin coconut oil producers that are exporting their products. These include Navida,
BICODE, Kentaste and Serendi (K). Approximately 30% of what these firms process is sold
locally and the rest is exported mainly to Europe and USA. Currently Kenya is a net import of
virgin coconut oil though it is processing approximately 35 tons annually. According to Figure
9.5, these processors derive more income/benefits than producers participating in this value chain.

Figure 6.5: Coconut Oil Value Chain

Copra
The Coconut
Coconut


Farmer


40

16



Coconut
Trader
Copra
Trader
20


Copra 20

Trader


42
42


Copra Oil Virgin Oil
Processor Processor




Crude Virgin
Oil
Coconut
Oil
160 600

Crude Oil

Virgin Oil


120 750

22
0
Food and non-food manufacturers:


Cooking oil, food ingredients, cosmetics,
soap, body
80
0
oil, hair and spa products
300 148 1200


Cooking Oil
Trader
So
ap
Cosmet
ic Other

450 188 1600


Consumers of Coconut oil & Coconut Oil Products

Numbers represent prices in KES/kg

Source: own presentation
By-products e.g., Husks

Expected Situation
Production
It is expected that farmers will produce enough nuts for processing products of this
value chain. Approximately 17 nuts are usually required to extract a litre
(approximately 1 kg) of coconut oil. The weight of an average piece of coconut is about
0.8 Kg. Thus 13.6 kg of nuts are required for the production of 1 kg of oil. In the
country, the amount of coconut oil currently being imported is 4,659,415 Kg (KCDA,
2013). This is the amount targeted to be produced by local processors by 2018.
However, it is important to note that the demand for oil will continue to rise due to
population increase, lifestyle changes and increased preference for health foods such as
coconut oil. It is assumed this increase will be 5% per year.

To offset the current annual coconut oil imports by 2018, farmers will be expected to
increase their produce gradually and eventually achieving 76,041,652.80 kg or
95,052,066 pieces of coconut by that year. This converts to a total of 1,357,886.66 trees
(assuming that a single tree produces 70 nuts per year) for coconut oil only. If this trend
is maintained the country will even be exporting some surplus coconut oil by 2019
(Table 6.3).

Table 6.3: Projection of Expected Production of Nuts and Oil (2014-2018)

2014 2015 2016 2017 2018 2019
1. Mature trees
harvested 452,629 678,943 905,258 1,131,572 1,357,887 1,584,201
2. Amount of nuts
processed (pieces) 31,684,022 47,526,033 63,368,044 79,210,055 95,052,067 110,894,077
3. Amount of nuts
processed (kg) 25,347,218 38,020,826 50,694,435 63,368,044 76,041,653 88,715,262
4. Oil produced
4,659,415

and sold (kg) 1,863,766 2,795,649 3,727,532 5,591,298 6,523,181
5. Oil imports
(kg) 4,892,386 5,137,005 5,393,855 5,663,548 5,946,725 6,244,062
6. Oil imports less
oil produced in kg
(5-4) 3,028,620 2,341,356 1,666,323 1,004,133 355,427 - 279,119

The oil produced and sold in 2017 is the current import volume (see
KCDA, 2013)

Source: own projection
Processing
The extraction of the coconut oil is a complex process which requires use of various technologies.
It is therefore expected that by 2018 processors will have formed common interest
groups/associations to scale up oil extraction to medium and large scale levels and to increase
their bargaining power. They will be expected to produce 5,591,298 kg of oil by this year (see
Table 6.3). It is therefore expected that they will be accessing machinery for medium scale and
large processing depending on the size of the group. Through support from financers or creditors,
processors or processor groups will be expected to acquire a set of machinery which has a
screening machine, boiler, digesters, press, clarifier and generator. This machine produces 0.5 tons
of coconut oil/hour. Large scale processors could acquire a refinery which would comprise
elements such as hammer mill, bucket elevator, screw press and conveyor, centrifuge, vibratory
sieve, micro filter, filtered oil storage tanks, crude coconut oil tanks and volumetric filling
machine. The refinery produces 1 ton of coconut oil/ton.

Distribution and Marketing
The coastal region serves as the main coconut oil consumption area due to the tradition of relying
on coconut products. Thus most of the coconut oil will be distributed in this region. To expand the
market, awareness creation of the nutritional value of coconut oil and its health benefits will be
done in other parts of the country. For the sale of the surplus, additional markets will be explored
in Uganda, Tanzania, Rwanda, and Ethiopia. Some of the strategies to be used to increase sales
and consumption of coconut oil and its products will include advertisement in print media, TVs,
radios, road shows and trade exhibitions. Quality coconut oil will also be promoted in foreign
markets (mainly through trade shows) in order to capture emerging markets in the European
Union and sub-Saharan Africa.

Value chain enablement
Farmers, processors and traders will be mobilized to form cooperatives/associations to facilitate
training and accessibility of external resources such as credit. Through private-public partnerships,
a standard for coconut oil will be developed. Awareness creation of coconut oil standard will be
done through workshops, brochures, pamphlets, local print media, radio and TVs. This will be
done to enhance harmonization of local, regional and international trade of coconut oil and its
acceptability. Government institutions will also be involved in setting up demonstration models for
farmers and processors in order to enhance transfer of necessary knowledge and thereby increase
productivity of the value chain.

It is expected that KCDA and KALRO will build capacity of farmers and processors by enabling them
to access quality seeds and oil processing machinery. KEPHIS is expected to test the quality of
coconut seedlings in order to ascertain that they are of the high quality and eliminate any risk of pest
and diseases. KEBS is expected to ensure maintenance of quality of coconut oil and train processors
on proper packaging in order to attain the desired internationally accepted standards. The organization
will also be involved in providing quality standard stickers to processors in order to promote regional
and international marketability of the coconut oil products. Infrastructure conditions in the production
and processing areas will need to be improved in order to facilitate coconut transportation and also
enhance marketing of coconut oil in both locally and regional markets.

Value chain Support
Credit services from banks, farmer cooperatives, NGOs and other organizations will be required to
promote coconut oil production. Input suppliers such as nursery operators, agro-chemical and fertilizer
traders will be provided with necessary incentives in order to enhance input accessibility by farmers. In
particular, the government will be advised to continue providing subsidized fertilizers to coconut
farmers. Coconut tree nurseries will be increased in number as demand for seedlings increase.

6.4.4 Coconut by-products
Coconut by-products considered in this value chain include shell, husk (coir/firbre) and cake.
The husk will be used to process coco peat and copra cake (also referred to as coir pith, coir fiber
pith, coir dust, or simply coir).

Current Situation
The current technology of processing coir fibre involves mechanical extraction of fibre from the
husk using a decorticating machine. The fibre is then classified into three classes: the long,
medium and short fibre. Coir fibre is of much value because of its natural resilience, durability,
resistance to dampness and anti-termite characteristics.
The current biggest market in Kenya for coir fibre is the Prisons Department. There are efforts
to expand the local market to include manufacturers of mattresses, mat weavers and car
upholstery manufacturers. Some stakeholders are also exploring weaving of geo-textiles. These
will target greenhouse farmers, dam and road constructors (for use in the prevention of soil
erosion), and sport stadia management (growing grass in stadia). The price of the fibre ranges
from KES 15-40 per kg depending on the nature of the final product (Figure 6.6).

Coco peats market share of plant growing media (coco peat, peat moss, etc.) in Kenya amounts
to approximately KES 120 million. Currently the country imports coco peat amounting KES 94
million annually. However, the country has also annual imports of about KES 5 million
(KCDA, 2013). The demand for coco peat has been increasing due to environmental concerns in
the flower industry. To-date most flower producers are using biodegradable products and coco
peat is one of them. Thus the Kenyan flower industry is the main consumer of this product. As
Figure 6.6 indicates processors of coco peat have higher benefits than other actors in the value
chain.

Figure 6.6: Coconut By-Products Value Chain


Coconut





Fresh

Coconu
t for
Other
Uses















Coconut

Peat
Block

80



The Coconut Coconut
Virgin
Coconut
Oil

Farmer





Copra Oil
Processor
Coconut
Husks 8

4
Coconut Husk
Trader
Copra Cake
Trader


10

6

Coconut Husk
Processor
Consumers of Coconut
Copra

Cake (Farmers etc)



Coconut Coir

Fibre

36

Coco Peat Block Trader Coconut Fibre
Trader

110 40

Flower & Seedling

Gro
wers

Numbers represent prices in KES/kg

Source: own presentation

Copra Cake

Producers of mats, car
upholstery, flower
holders, chairs etc
The copra cake is important as an ingredient of animal feeds. Currently the level of production is
very low due to low processing capacity and competition with other animal feeds. In particular,
demand for copra cake in the coastal region where most of the coconut is produced is very low.
Expected Situation
De-husking and processing
The production of coconut by-products through de-husking and processing is expected to increase
and offset imports by 2018. This is because more coconut oil, desiccated coconut and coconut
milk products will increase whose by-products will form the raw materials for this value chain.
This means that as the volume of processed fresh coconut increases, more husks (coir/fiber), cake
and shell will be produced. Among the by-products produced, cocopeat is expected to be
prioritized due to the high local demand in the flower industry.

The by-products will be processed at all levels: local (household), medium (mainly individual
entrepreneurs and small groups) and large scale (large companies) levels. Machinery for washing,
heat-treatment, screening and grading will be availed in the market and full accessibility is
expected to be achieved by 2016.

Marketing and distribution channels
Local, regional and international markets will be targeted. Emerging regional markets in Burundi,
Rwanda, Uganda and Tanzania will be identified. Awareness will also be created through
continuous advertisements in order to reach more consumers in different parts of the country.

Value chain enablement
Research will be done on the awareness of and perceptions on locally processed by-products.
Other forms of research to be conducted will be on achievement of zero waste and its linkage to
climate change. Trade and road shows will be conducted to promote the by-products in the local
markets. Storage yards for the husks (fibre/coir), shells and cakes will be constructed through
public-private partnerships. Farmers will also be mobilized and trained on local processing of the
by-products in their farms.

Value chain support
Besides benefiting from financial and credit service providers, this value chain will need support
from non-governmental organizations and other private sector players involved in capacity
building of actors in the coconut industry. This will help in improving skills of processing coconut
by-products.

6.4.5 Coconut (palm) wine and related products
Wine production involves tapping, fermentation and marketing. Over the years, toddy demand has
been constant while supply has been dependent on the rainfall patterns. During the rainy season,
toddy production is generally low. The production steadily rises as the long rains subside. The low
production level during the rainy season increases the demand, pushing toddy prices upwards,
while during the high toddy production season supply is higher than demand. This at times leads
to post harvest loses and poor prices at the farm level.

Current Situation
Coconut wine (toddy) is regarded as one of the main traditional products of the coconut tree. In
some cases it is viewed as controversial product (mainly after fermentation) and therefore
embroiled in traditional, faith-based (religious) and legality issues. Toddy is tapped by special
traditionally skilled people who are paid about KES 50/kg. The traders (middlemen) sell it at
KES 100/kg. It then retails at KES 150/kg (Figure 6.7). It is estimated that there are over 6,500
toddy pubs (Mangwes) in the coastal region. On average each Mangwe sells an average of 60
litres or kgs of toddy per day.

In 2012, approximately 153,311,377 litres of toddy were produced and sold at a total value of
7,236,523,322 (KCDA, 2013). KCDA has made efforts to modernize the distribution and
consumption of toddy through legislation and regulation, though not everything has been
streamlined. The toddy pubs (Mangwes) are required by legislation to meet certain minimum
hygiene standards before they are licensed to operate. However some operators have failed to
comply.

64

Regarding the coconut sap or sugar syrup, there are no commercial quantities being tapped despite
the huge potential for income generation from this activity. The main hindrance has been lack of a
consistent market for sugar syrup. However, there is some tapping done by individual households,
mainly for home consumption.

Figure 6.7: Coconut Toddy Value Chain

The Coconut

Farmer






Tapped Toddy



50


Toddy Traders


100


Toddy Clubs / Ba


150

Consumers of palm wine

Numbers represent prices in KES/kg

Source: own presentation
Expected Situation
Since palm wine is neither exported nor imported, it is difficult to predict the production level to
be achieved by 2018. Thus, pessimistically, it is recommended that the current production level
be doubled by 2018.

Tapping
To double the current production level by 2018, farmers are expected to be equiped with better
tapping skills. Thus they are expected to be trained on important practices like how to make
incisions on coconut trees and how to cut the flourescent from the base in order to prevent toddy
from clogging. Farmers will also require training on good agronomic practices such as regular
weeding, application of manure/fertilizers as well as pests and disease control. The focus will be
to scale up the current tapping that uses few specialized tappers to large scale tapping that will
rely on a pool of well trained individuals who will be employees of brewing companies. These
companies are expected to initiate long term tapping contractual agreements with farmers.

Fermentation
The fermentation of toddy will be scaled up as the process will be done at the factories and not at
homesteads or Mangwes. Toddy will be distilled to yield high quality alcoholic drinks with high
nutritional value and sold at premium prices. It is expected that through public-private
partnerships equipments such as distillers, stabilizers, coolers, storage and packaging machines
and bottles will be accessed by palm wine investors.

Marketing and distribution
With large brewing companies being involved in the industry, more local markets at the Coast
region and in other counties will be reached. It is expected that regional markets within the East
Africa Community such as Tanzania, Burundi and Uganda will be more important. Kenya alone
has a lot of potential for wine consumption as Nairobi, Kisumu, Nakuru, Thika and Eldoret have
large populations that can consume palm wine. It is expected that palm wine will be promoted
and marketed alongside other local brews.
Value chain enablement
Standards on the production, fermentation, packaging and marketing of palm wine will be
developed in order to establish sanity in the palm wine industry. Research on soil structure and
pH level will be done to determine areas that would produce the best toddy for fermentation and
subsequent processing into palm wine.
Farmers in common interest groups will be empowered through training and enabled to
establish long term contractual agreements with brewers. Creation of awareness of the palm wine
as an alternative alcoholic drink will be done in different regions of Kenya and in neighboring
countries. Palm wine will also be registered with NACADA as an alcoholic drink in order to
increase its marketability and acceptability locally and regionally. Through workshops and
seminars police and local people will be educated on the differences between palm wine and
local brews.

Value chain Support
Companies and common interest groups/associations interested in establishing brewing factories
will facilitated to access credit from the Coconut Development Fund and other sources at
affordable interest rates. Alternatively, credit from local microfinance institutions (MFIs) will be
availed to farmers at affordable interest rates to enable them to start toddy fermentation
businesses. Such credit providers will be KCB, Cooperative and Equity banks, among other
finacial institutions that have shown interest in supporting agribusinesses. Other support
institutions will included NGOs such as MESPT which will capacity build farmers to enable
them venture into wine production.

6.4.6 Coconut Wood and Leaves
The coconut trunk is harvested for wood after the tree has outlived its productive economic life, in
terms of nut and toddy production. This is normally done after about 60 years. The distinctively
patterned timber coco wood is used to make handicraft, traditional utensils, furniture and other
household items. The timber trunks are used in construction and particularly as a flooring
material. The leaves are harvested for making brooms as well as roofing materials commonly
called makuti, which are ideal thatching materials in hot areas.
The Current Situation
With a high demand for timber and makuti, there has been indiscriminate logging that does not
select the senile or unproductive trees. Particularly with makuti, some farmers have started
harvesting leaves and drying them under the sun instead of waiting for them to fall off the trees.

At an average price of KES 12.80 per piece of makuti, it is estimated that farmers earned about
KES 1.7 billion in 2013. Currently the production level of makuti stands at 132 million pieces
annually.

The brooms made from coconut leaves however face stiff competition from those made from
other materials. The wood fetches approximately KES 1200 per piece at the farm gate level
(Figure 6.8). Currently it is commonly used to make furniture and traditional artefacts which are
sold mainly to tourists.

Expected Situation
This value chain will involve production, processing and marketing stages. If well-structured and
promoted it has potential to generate high income for the actors and create employment for
youths involved in the construction industry. However, promotion of this value chain has to be
handled cautiously as it can lead to destruction of productive coconut plantations if harvesting of
wood and leaves is not regulated.

Figure 6.8: Coconut Wood and Leaves Value Chain

The Coconut

Farmer

Mature Coconut Trees&

Leaves
Tree Trunk

1000

Coconut Tree Trunk

Traders

1200

Coconut Material Workshops

(Furniture, tiles, artifacts)
Artefac
ts
Furnitu
re
Tile
s

1500 4000
1700

You might also like