Professional Documents
Culture Documents
FACULTY OF ENGINEERING
SECOND SEMESTER EXAMINATIONS SECOND SEMESTER EXAMINATIONS SECOND SEMESTER EXAMINATIONS SECOND SEMESTER EXAMINATIONS
MAY 2010 MAY 2010 MAY 2010 MAY 2010
PROGRAMME BEng (Hons) Electronic & Communication Engineering
MODULE NAME Wireless Technologies
DATE Thursday
13 May 2010
MODULE CODE ELEC 4023Y(5)
TIME 09.30 12.30 Hrs DURATION 3 Hrs
NO. OF
QUESTIONS SET
4 NO. OF QUESTIONS
TO BE ATTEMPTED
4
INSTRUCTIONS TO CANDIDATES
Answer ALL questions.
Page 1 of 2
WIRELESS TECHNOLOGIES ELEC 4023Y(5)
Question 1
(a) What is the function and features of a wireless repeater? [5 marks]
(b) Explain how the use of wireless repeaters reduces throughput. [3 marks]
(c) Differentiate between visual line of sight and RF line of sight. [5 marks]
(d) Explain what you understand by the term adjacent channel interference.
Illustrate your answer with an appropriate diagram. [5 marks]
(e) Explain what is an Intentional Radiator. [4 marks]
(f) An access point is transmitting at 50 mW. The signal loss between the access
point and the antenna is 1 dB, and the access point is using a 5 dBi antenna.
Calculate the IR and the EIRP values. [3 marks]
Question 2
(a) Write short notes on the following standards:
(i) 802.11
(ii) 802.11b
(iii) 802.11g
(iv) 802.11n [3 x 4 marks ]
(b) Explain what you understand by B/G mode (mixed mode). [3 marks]
(c) Explain 802.11b Direct Sequence Modulation. Illustrate your answer with an
example. [6 marks]
(d) Explain 802.11b Scalability. [4 marks]
Page 2 of 2
WIRELESS TECHNOLOGIES ELEC 4023Y(5)
Question 3
(a) What are the advantages and disadvantages of FDMA with respect to TDMA
or CDMA? [6 marks]
(b) What are the three distinct states in the process of authentication and
association? Elaborate on each of these. [9 marks]
(c) Distinguish between Continuous Aware Mode and Power Save Polling.
[5 marks]
(d) Explain briefly the steps followed by stations in order to pass traffic between
peers. [5 marks]
Question 4
(a) Explain roaming. [3 marks]
(b) Briefly explain how too much cell overlap may cause roaming problems.
[3 marks]
(c) Briefly describe 3 methods can be used to fix a hidden node problem.
[3 marks]
(d) Explain what you understand by the Near/Far Problem, and what can be
done to correct the problem. [8 marks]
(e) What devices cause RF Interference? [5 marks]
(f) What is the purpose of Control Frames in wireless communications? Give
examples of control frames. [3 marks]
END OF QUESTION PAPER
/ph