Professional Documents
Culture Documents
PEEK POLYARYLETHERKETONE
PEEK is a high-performance thermoplastic that is manufactured by Victrex. This material has an extraordinary combination of mechanical, structural and chemical resistant properties. Afton Plastics processes the following grades of PEEK: 450G (virgin), 450CA30 (carbon fiber reinforced) and 450FC30 (bearing grade).
MATERIAL CLASSIFICATIONS:
Mil-P 46183 Amendment 2 dated 1 July 1999 Type Inonreinforced plastic Type III Class 230% carbon fiber reinforced
PRODUCT BENEFITS:
Chemical resistance UL94 V-0 Flammability rating down to .059" Wear resistance Service temperature: 50 Deg. F to +500 Deg. F Hydrolysis resistance Radiation resistance FDA compliant
TYPICAL APPLICATIONS:
Thrust washers Pump gears Compressor valve plates Electrical connectors Valve seats and seals Bearings and bushings
KEY MARKETS:
Aerospace and Defense Food Processing
Peek and Victrex are registered trademarks of Victrex plc.
Medical Oil and Gas Semiconductor Automotive and Electrical Industrial and Nuclear
MEMBER
ASTM METHOd
UNIT
450G
450FC30 450CA30
THErMaL
Melting Point Heat Distortion Temperature (264 psi) Coefficient of Thermal Expansion (< 289F) Continuous Use Temperature Thermal Conductivity Flammability (1.45 mm thickness) C-177 UL 94 DSC D-648 D-696 C C 10 F C Btu-in/hr-ft2-F
-5 -1
ELEcTrIcaL
Surface Resistivity Volume Resistivity Dielectric Strength (0.05 mil film) Dielectric Constant, 23C, 50 Hz-10 kHz Dissipation Factor, 23C, 1 MHz
1
1.4 x 105
Information provided by Victrex, Inc. H Victrex and PEEK are registered trademarks of Victrex Note: The data provided in this table are typical for the resins tested and do not represent product specifications.
MEMBER
IAPD