Professional Documents
Culture Documents
Installation Directions for the Reciprocator (Single head and Multi heads)
TOOLS REQUIRED
Phillips Screwdriver 3mm T Handle 2.5mm T Handle 2.0mm T Handle
Head Disassembly
Tension Unit
1) After removing Tension Plate Cover, remove the Wheel Sensor Board Connector. 2) Remove Head Face Plate (Upper). 3) After removing screws for the Head, disassemble Head by removing the 3.0mm set screws.
Guide Rail
RECIPROCATOR REPLACEMENT
1- Remove the Needle Bar by lifting it up. 2- Remove the Reciprocator from the Crank Rod. 3- Replace with the new Reciprocator.
Crank Rod
Part #: AS-003447-00
TOOLS REQUIRED
Phillips Screwdriver 3mm T Handle 2.5mm T Handle 2.0mm T Handle
Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 5a
Fig. 6
Fig. 7
Fig. 8
4. Carefully slide the shaft up through the top of the head until the reciprocator assembly is free of the shaft See fig. 9. 5. Remove the reciprocator assembly by sliding left until it is free of the driving lever. Note: The needle bar drive link and collar may come loose also. Take note of their locations for proper reassembly. See fig. 10.
Fig. 9
Fig. 10
Fig 11
Fig. 12
Part # (03600010H000
TOOLS REQUIRED
Phillips Screwdriver 3mm T Handle 2.5mm T Handle 2.0mm T Handle
Fig.1
Fig.2
Fig.3
Fig.4
Fig.5
Fig.5a
Fig.6
Fig.7
Fig.8
4. Remove 3 screws on left side of arm. See Fig. 9. 5. Remove Presser Foot Driving Base (brown color), see Fig.10, By lifting and tilting up toward center of arm. 6. Carefully slide the reciprocator shaft up through the top of the head until the reciprocator assembly is free of the shaft. See Fig.11. 7. Remove the reciprocator assembly by sliding left until it is free of the driving lever. NOTE: The needle bar drive link and collar will come loose also. Take note of their locations for proper reassembly. See Fig.12.
Fig.9
Fig.10
Fig.11
Fig.12
Fig.13
Fig.14
Fig.15