Professional Documents
Culture Documents
FCC STATEMENT
This equipment has been tested and found to comply with the limits for a Class A digital device, pursuant to part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference when the equipment is operated in a commercial environment. This equipment generates, uses, and can radiate radio frequency energy and, if not installed and used in accordance with the instruction manual, may cause harmful interference to radio communications. Operation of this equipment in a residential area is likely to cause harmful interference in which case the user will be required to correct the interference at his own expense. This device complies with part 15 of the FCC Rules. Operation is subject to the following two conditions: 1) 2) This device may not cause harmful interference. This device must accept any interference received, including interference that may cause undesired operation. Any changes or modifications not expressly approved by the party responsible for compliance could void the users authority to operate the equipment.
CE Mark Warning
This is a class A product. In a domestic environment, this product may cause radio interference, in which case the user may be required to take adequate measures.
SAFETY NOTICES
Caution: Do not use this product near water, for example, in a wet basement or near a swimming pool. Avoid using this product during an electrical storm. There may be a remote risk of electric shock from lightning. III
CONTENTS Package Contents ..........................................................................................................................1 Chapter 1 About this Guide...........................................................................................................2 1.1 1.2 1.3 Intended Readers .........................................................................................................2 Conventions..................................................................................................................2 Overview of This Guide ................................................................................................2
Chapter 2 Introduction ..................................................................................................................6 2.1 2.2 2.3 Overview of the Switch .................................................................................................6 Main Features...............................................................................................................6 Appearance Description ...............................................................................................7 2.3.1 2.3.2 Front Panel ........................................................................................................7 Rear Panel .........................................................................................................8
Chapter 4 System ....................................................................................................................... 11 4.1 System Info................................................................................................................. 11 4.1.1 4.1.2 4.1.3 4.1.4 4.2 System Summary............................................................................................. 11 Device Description ...........................................................................................13 System Time ....................................................................................................13 System IP.........................................................................................................15
User Manage ..............................................................................................................16 4.2.1 4.2.2 User Table........................................................................................................16 User Config ......................................................................................................16
4.3
System Tools ..............................................................................................................18 4.3.1 4.3.2 4.3.3 4.3.4 4.3.5 Config Restore .................................................................................................18 Config Backup..................................................................................................18 Firmware Upgrade ...........................................................................................19 System Reboot ................................................................................................20 System Reset...................................................................................................20
4.4
Access Security ..........................................................................................................20 4.4.1 4.4.2 4.4.3 Access Control.................................................................................................20 SSL Config.......................................................................................................22 SSH Config ......................................................................................................23
LAG ............................................................................................................................33 5.2.1 5.2.2 5.2.3 LAG Table ........................................................................................................34 Static LAG ........................................................................................................35 LACP Config ....................................................................................................36
5.3
Traffic Monitor .............................................................................................................38 5.3.1 5.3.2 Traffic Summary...............................................................................................38 Traffic Statistics ................................................................................................39
5.4
MAC Address..............................................................................................................40 5.4.1 5.4.2 5.4.3 5.4.4 Address Table ..................................................................................................41 Static Address ..................................................................................................43 Dynamic Address .............................................................................................44 Filtering Address ..............................................................................................46
Chapter 6 VLAN..........................................................................................................................48 6.1 802.1Q VLAN..............................................................................................................49 6.1.1 6.1.2 6.2 6.3 VLAN Config ....................................................................................................51 Port Config .......................................................................................................53
MAC VLAN .................................................................................................................55 Protocol VLAN ............................................................................................................56 6.3.1 6.3.2 6.3.3 Protocol Group Table .......................................................................................59 Protocol Group.................................................................................................59 Protocol Template ............................................................................................60
Application Example for 802.1Q VLAN .......................................................................61 Application Example for MAC VLAN...........................................................................63 Application Example for Protocol VLAN......................................................................64 GVRP .........................................................................................................................66
Chapter 7 Spanning Tree ............................................................................................................70 7.1 STP Config .................................................................................................................75 7.1.1 7.1.2 7.2 7.3 STP Config.......................................................................................................75 STP Summary..................................................................................................77
Port Config..................................................................................................................77 MSTP Instance ...........................................................................................................79 7.3.1 7.3.2 7.3.3 Region Config ..................................................................................................79 Instance Config ................................................................................................80 Instance Port Config.........................................................................................81
7.4
STP Security...............................................................................................................83 V
Chapter 8 Multicast.....................................................................................................................90 8.1 IGMP Snooping ..........................................................................................................92 8.1.1 8.1.2 8.1.3 8.1.4 8.2 Snooping Config ..............................................................................................93 Port Config .......................................................................................................94 VLAN Config ....................................................................................................95 Multicast VLAN ................................................................................................97
Multicast IP ...............................................................................................................100 8.2.1 8.2.2 Multicast IP Table ...........................................................................................101 Static Multicast IP...........................................................................................101
8.3
8.4
Packet Statistics........................................................................................................105
Chapter 9 QoS..........................................................................................................................107 9.1 DiffServ ..................................................................................................................... 110 9.1.1 9.1.2 9.1.3 9.1.4 9.2 Port Priority .................................................................................................... 110 Schedule Mode .............................................................................................. 111 802.1P Priority ............................................................................................... 112 DSCP Priority................................................................................................. 112
Bandwidth Control .................................................................................................... 114 9.2.1 9.2.2 Rate Limit....................................................................................................... 114 Storm Control ................................................................................................. 115
9.3
Voice VLAN .............................................................................................................. 116 9.3.1 9.3.2 9.3.3 Global Config ................................................................................................. 118 Port Config ..................................................................................................... 119 OUI Config .....................................................................................................120
Chapter 10 ACL ..........................................................................................................................122 10.1 Time-Range ..............................................................................................................122 10.1.1 10.1.2 10.1.3 10.2 Time-Range Summary ...................................................................................122 Time-Range Create........................................................................................123 Holiday Config................................................................................................124
ACL Config ...............................................................................................................124 10.2.1 10.2.2 ACL Summary................................................................................................125 ACL Create ....................................................................................................125 VI
Policy Config.............................................................................................................129 10.3.1 10.3.2 10.3.3 Policy Summary .............................................................................................129 Policy Create..................................................................................................130 Action Create .................................................................................................130
10.4
Policy Binding ...........................................................................................................131 10.4.1 10.4.2 10.4.3 Binding Table .................................................................................................131 Port Binding ...................................................................................................132 VLAN Binding.................................................................................................132
10.5
Chapter 11 Network Security ......................................................................................................136 11.1 IP-MAC Binding ........................................................................................................136 11.1.1 11.1.2 11.1.3 11.1.4 11.2 Binding Table .................................................................................................136 Manual Binding ..............................................................................................137 ARP Scanning................................................................................................139 DHCP Snooping.............................................................................................140
ARP Inspection .........................................................................................................146 11.2.1 11.2.2 11.2.3 ARP Detect ....................................................................................................150 ARP Defend ...................................................................................................151 ARP Statistics ................................................................................................152
11.3 11.4
DoS Defend ..............................................................................................................153 802.1X ......................................................................................................................155 11.4.1 11.4.2 11.4.3 Global Config .................................................................................................159 Port Config .....................................................................................................161 Radius Server ................................................................................................162
Chapter 12 SNMP.......................................................................................................................164 12.1 SNMP Config ............................................................................................................166 12.1.1 12.1.2 12.1.3 12.1.4 12.1.5 12.2 12.3 Global Config .................................................................................................166 SNMP View ....................................................................................................167 SNMP Group..................................................................................................168 SNMP User ....................................................................................................169 SNMP Community..........................................................................................171
12.3.2 12.3.3
Chapter 13 Cluster......................................................................................................................180 13.1 NDP ..........................................................................................................................181 13.1.1 13.1.2 13.1.3 13.2 Neighbor Info .................................................................................................181 NDP Summary ...............................................................................................182 NDP Config ....................................................................................................184
NTDP........................................................................................................................185 13.2.1 13.2.2 13.2.3 Device Table ..................................................................................................185 NTDP Summary .............................................................................................186 NTDP Config..................................................................................................187
13.3
Cluster ......................................................................................................................189 13.3.1 13.3.2 Cluster Summary ...........................................................................................189 Cluster Config ................................................................................................190
13.4
Chapter 14 Maintenance ............................................................................................................195 14.1 System Monitor.........................................................................................................195 14.1.1 14.1.2 14.2 CPU Monitor ..................................................................................................195 Memory Monitor .............................................................................................196
Log............................................................................................................................197 14.2.1 14.2.2 14.2.3 14.2.4 Log Table .......................................................................................................198 Local Log .......................................................................................................198 Remote Log ...................................................................................................199 Backup Log ....................................................................................................200
14.3
14.4
Appendix A: Specifications .........................................................................................................205 Appendix B: Configuring the PCs ...............................................................................................206 Appendix C: Load Software Using FTP ......................................................................................209 Appendix D: 802.1X Client Software ..........................................................................................214 Appendix E: Glossary .................................................................................................................222
VIII
Package Contents
The following items should be found in your box: One JetStream L2 Lite Managed Switch One power cord One console cable Two mounting brackets and other fittings Installation Guide Resource CD for TL-SG3216/TL-SG3424 Switch, including:
Note: Make sure that the package contains the above items. If any of the listed items are damaged or missing, please contact with your distributor.
1.2 Conventions
In this Guide the following conventions are used: