Professional Documents
Culture Documents
,I',
.' 'i.
.
SOOPE A polyester polyurethane coating to provide a durable matt finish for industrial environments. It has excellent colour and r=; yloi>s retention properties. When fully cured, it forms an exllernely tough and abrasion resistant finish. TIle product compatible with epoxy and PU undercoats.
J$
Isocyanate
Chemical
EXPOSURES
Resistance
SPLASH
:
MILD FVMES I
OUmOOR nESIST
ANct _
Mixing
Ratio:
Rasp, : Cnlnlys/
- 1() . 1 by volume
Pot Life:
App'ic:ltion
3- 4 hours
: /Jrw;11 r;ollw}//Iioll:
.1',
Suivellls
SClIl
"
Co responding TI)ooretic;ll
WAler
Spreading
Drying Time:
Temperature
'. within 30 rnins. :6- 8 hours : Overnight
Resistance:
CDo\ioUDUS Intermittent
TOUCH
HAI'JDLE HARD
: 930 C
: 120
Very Good
,. .,
j"
C 'rlng Time: 7
Ovcrcoating MIN
Q3YS
Good
to
interval: : Overnight ..
0
Resistance:
Very Good
: 5 days
Above 22 C
.\"t ., ~. "~;
:':,:'/Cb!our:'
;c.' , t','; .,'.' .. ' .
., .' '
Assori"i:lcf:s!ladcs
f
::.'. r;inilJb,~;Mon;:,;:~:"j
',1.',"._ ",,: .
';"
~\.4:
MENT NO
aOC
I~:
. ,"
<tPaCking'
,.,.
~~11 IJrs..
,", ,.~' '1\
u
01"
~.:.JQ.,; '\~'.~
---
'j
\SSUE.
'\
,
I
Life:
!:,I'i"iI(:d containnrs
IItJIIII;illt:IIIPt~I;'I'''l:
SANDIP IVli
DATA SHEET No., :'156',. '.
(~"
,,--\
. .
Issue- mite'
','
._ ll/~
, .,'
.'
,~
1,
."
. ...... '
"
..
~.,
Steell Remove grease, oil and other contaminants preferably by using Bison Degreasing Solvent. Blast clean to a minimum of Sa 2112 ' Swedll3h Standard SIS C6 59CX)' For severe corrosive conditions, blast to Sa 3 with a sulface profile not exceeding 35-40 mIcrons, If bl,..tl,~ is not practical, niake full use of mechanical tools alongwith manual chipping and wire brushing to remove loose ~ust and sea e to Sa, 2 ." , Swedish Standard SIS C6 590). Excessive burnishing of steel is to be avoided. Thoroughly dust down all surfaces.' Best results can be "." achieved if the manually cleaned surface Is primed with Protectomasuc Self Priming Surface Tolerant Coating. The surrace should be cld_n' and dry before application of appropriate undercoats. ,..
J' '
"',"::
' ,
I:
Concrete:
NEW CONCRETE:
Ensure that the concrete is cured for a minimum of three months. by sand sweeping. OLD CONCRETE:
and frile from laitance and other contaminants by waler Jel waahlng, coatings to ensure anchorage, possible, waterjet
Light aand blaat the aurface to remove all loosoly bound coatings and roughening up of firmly IIdherlng Clean and dry the surface beforo application of paint. In non critical areas where blasting is riot
Stir the base thoroughly and then mix ten parts base and one part catalyst by volume to uniform consistency. mlnutes and stir again before and during application, Brush I Apply preferably without thinninq. Conventional Spray:
etandard equipment at an atomising pressure of 3.5-4.9 kg/cm 2. Alrle Spray: Apply preferably without Ihinning. However, upto 5% Thinner 825 may be added if absolutely essential, depending on condltlohs. Use any standard equipment having pump ratio 40 : 1. Tip size 0.38 - 0.48 mm. Tip pressure 110 -1 ED Kg/cm2
Surfaqe Steel
1st Coat Zinc Anode 304 MZ or Epilux 4Z1R Primer Epllux 610 or Primer Epilux HB ZP Primer
PU
Matt
'" ,
-doEpilux 610 Primer or Epilux HB ZP Primer ." do- do-
Epilux 4 HB MIO
- do-
- do-
Notes:
1. Use of( the m.Q<ed paint within the stipulated pot life period.
2. Do not apply when temperature
I
'3:1'
C and
when relative humidity rises above 90%. Do not apply during fain, fog or mist.3. Brushes and spray equipment should be cleaned with Thinner 825 otherwise equipment is likely to be damaged.
I
to
4, Special care is to be taken to immediately close the partly use~ catalyst container since the is very susceptible atmospheric moisture. Please refer to the separate Safety Data Sh,t
I
available with detailed information.
D!SCL/\INlEf{
The Information contained within this Data Sheet is based on information preparation. believed to be reliable at the time of its to conduct all
The Company will not be liable for loss or da,mage howsoever caused including liability for negligence,
which may be suffered by the user of Ihe data contained herein. It is the users' responsibility
necessary tests to confirm the suitability of any product or system for their intended use. No guarantee of results is Implied ainne conditions or use are boyond our conlrol.
"I',L
Berger House,129 Park Street, Kolkata 700017 Phone :(033) 2229 9724 (5 lines) 12499754 (4 lines) Fax: 91-33-22499729/22499009 Email: NORTH: bpil_okh@inantraonline.com SOUTH: ppil_ch2@sify.coll) ... _ EAST: bpiLcl1@vsrll.net WEST: bpil_vsh@vsnl.net ',;,!' ;C.
. . ~:.I:(~