The Safety Data Sheets for catalog items are also available at www.merck-chemicals.com Page 1 of 6 1. Identification of the substance/mixture and of the company/undertaking Product Information Catalogue No.: 101322 Product name: Methyl orange (C.I. 13025) indicator ACS,Reag. Ph Eur Use of the Substance/Mixture Reagent for analysis, Pharmaceutical production and analysis
Company: Merck KGaA * 64271 Darmstadt * Germany * Phone:+49 6151 72-0 Emergency telephone: Please contact the regional Merck representation in your country. Responsible/issuing person: EQ-EPS * e-mail: prodsafe@merck.de
2. Hazards identification GHS Classification Acute toxicity, Category 3, Oral H301: Toxic if swallowed. EC Classification T; R25 For the full text of the R-phrases mentioned in this Section, see Section 16.
3. Composition/information on ingredients Formula CHNNaOS (Hill) CAS-No. 547-58-0 EC-No. 208-925-3 Molar mass 327,34 g/mol
4. First aid measures
After inhalation: fresh air.
After skin contact: wash off with plenty of water. Remove contaminated clothing.
After eye contact: rinse out with plenty of water.
If swallowed: give water to drink (two glasses at the most). Seek medical advice immediately. In exceptional cases only, if medical care is not available within one hour, induce vomiting (only in persons who are wide awake and fully conscious), administer activated charcoal (20 - 40 g in a 10% slurry) and consult a doctor as quickly as possible.
5. Fire-fighting measures
Suitable extinguishing media Water, Carbon dioxide (CO2), Foam, Dry powder
Specific hazards during fire fighting Combustible material Development of hazardous combustion gases or vapours possible in the event of fire. Fire may cause evolution of: Sulphur oxides, nitrogen oxides, nitrous gases
Safety Data Sheet according to Regulation (EC) No. 1907/2006
The Safety Data Sheets for catalog items are also available at www.merck-chemicals.com Page 2 of 6 Special protective equipment for fire-fighters In the event of fire, wear self-contained breathing apparatus.
Further information Suppress (knock down) gases/vapours/mists with a water spray jet. Prevent fire extinguishing water from contaminating surface water or the ground water system.
6. Accidental release measures
Personal precautions Avoid substance contact. Avoid inhalation of dusts. Ensure adequate ventilation.
Environmental precautions Do not empty into drains.
Methods for cleaning up Take up dry. Forward for disposal. Clean up affected area. Avoid generation of dusts.
7. Handling and storage Handling
Advice on safe handling Observe label precautions.
Storage
Further information on storage conditions Dry. Tightly closed. Keep in a well-ventilated place. Keep locked up or in an area accessible only to qualified or authorised persons.
Store at +5C to +30C.
8. Exposure controls/personal protection
Personal protective equipment Protective clothing should be selected specifically for the working place, depending on concentration and quantity of the hazardous substances handled. The resistance of the protective clothing to chemicals should be ascertained with the respective supplier.
Respiratory protection required when dusts are generated. Recommended Filter type: Filter P 2 (acc. to DIN 3181) for solid and liquid particles of harmful substances
Hand protection full contact: Glove material: Nitrile rubber Glove thickness: 0,11 mm Break through time: > 480 min splash contact: Glove material: Nitrile rubber Glove thickness: 0,11 mm Break through time: > 480 min
Safety Data Sheet according to Regulation (EC) No. 1907/2006
The Safety Data Sheets for catalog items are also available at www.merck-chemicals.com Page 3 of 6 The protective gloves to be used must comply with the specifications of EC irective 89/686/EEC and he resultant standard EN374, for example. KCL 741 Dermatril L (full contact), KCL 741 Dermatril L (splash contact). The breakthrough times stated above were determined by KCL in laboratory tests acc. to EN374 with samples of the recommended glove types. This recommendation applies only to the product stated in the safety data sheet and supplied by us as well as to the purpose specified by us. When dissolving in or mixing with other substances and under conditions deviating from those stated in EN374 please contact the supplier of CE- approved gloves (e.g. KCL GmbH, D-36124 Eichenzell, Internet: www.kcl.de).
Eye protection Safety glasses
Hygiene measures Immediately change contaminated clothing. Apply skin- protective barrier cream. Wash hands and face after working with substance. Work under hood. Do not inhale substance.
9. Physical and chemical properties Form solid
Colour orange
Odour weak characteristic odour
pH ca. 6,5 at 5 g/l 20 C
Viscosity, dynamic no data available
Melting point > 300 C
Boiling point no data available
Ignition temperature no data available
Flash point no data available
Oxidizing properties no data available
Flammability no data available
Lower explosion limit no data available
Upper explosion limit no data available
Vapour pressure no data available
Relative vapour density no data available
Density no data available
Bulk density ca.200 - 400 kg/m3
Safety Data Sheet according to Regulation (EC) No. 1907/2006
The Safety Data Sheets for catalog items are also available at www.merck-chemicals.com Page 4 of 6 Solubility/qualitative no data available
Water solubility ca.5 g/l at 20 C
Partition coefficient: n- octanol/water log Pow: -0,66 Method: (calculated) (Lit.) No bioaccumulation is to be expected (log Pow <1). Evaporation rate no data available
10. Stability and reactivity
Conditions to avoid no information available
Materials to avoid with
Nitrous acid and other nitrosating agents
Release of:
Nitrosamine
Violent reactions possible with:
Strong oxidizing agents
Hazardous decomposition products in the event of fire: See chapter 5.
Further information The following applies in general to flammable organic substances and preparations: in correspondingly fine distribution, when whirled up a dust explosion potential may generally be assumed.
11. Toxicological information
Acute oral toxicity LD50 rat Dose: 60 mg/kg (RTECS) Symptoms: We have no description of any toxic symptoms. absorption
Acute dermal toxicity Symptoms: We have no description of any toxic symptoms. absorption
Eye irritation Possible damages: slight irritation Further information The following applies to azo dyes in general: azo dyes containing a carcinogenic aryl amine component are suspected of possessing a carcinogenic potential. It is therefore recommended that the substance be handled as if it possessed the properties of the basic amine. Safety Data Sheet according to Regulation (EC) No. 1907/2006
The Safety Data Sheets for catalog items are also available at www.merck-chemicals.com Page 5 of 6 Under given conditions, contact with nitrites or nitric acid can lead to the formation of nitrosamines, which have shown themselves to be carcinogenic in animal experiments. Further data: Other dangerous properties can not be excluded. Handle in accordance with good industrial hygiene and safety practice.
12. Ecological information
Partition coefficient: n-octanol/water log Pow: -0,66 Method: (calculated) (Lit.) No bioaccumulation is to be expected (log Pow <1). Additional ecological information We have no quantitative data concerning the ecological effects of this product. Further information on ecology Do not allow to enter waters, waste water, or soil!
13. Disposal considerations
Product Chemicals must be disposed of in compliance with the respective national regulations. Under www.retrologistik.de you will find country- and substance-specific information as well as contact partners. Packaging Merck product packaging must be disposed of in compliance with the country-specific regulations or must be passed to a packaging return system. Under www.retrologistik.de you will find special information on the respective national conditions as well as contact partners.
14. Transport information ADR/RID UN 2811 TOXIC SOLID, ORGANIC, N.O.S. (METHYL ORANGE), 6.1, III IATA UN 2811 TOXIC SOLID, ORGANIC, N.O.S. (METHYL ORANGE), 6.1, III IMDG UN 2811 TOXIC SOLID, ORGANIC, N.O.S. (METHYL ORANGE), 6.1, III EmS F-A S-A The transport regulations re cited according to international regulations and in the form applicable in Germany. Possible national deviations in other countries are not considered.
15. Regulatory information GHS-Labelling Hazard pictograms
Signal word Safety Data Sheet according to Regulation (EC) No. 1907/2006
The Safety Data Sheets for catalog items are also available at www.merck-chemicals.com Page 6 of 6 Danger
Hazard statements H301: Toxic if swallowed.
Precautionary statements P309 + P310: IF exposed or if you feel unwell: Immediately call a POISON CENTER or doctor/physician.
CAS-No. 547-58-0 Labelling according to EC Directives Symbol(s): T Toxic
R-phrase(s): 25 Toxic if swallowed. S-phrase(s): 37-45 Wear suitable gloves. In case of accident or if you feel unwell, seek medical advice immediately (show the label where possible). EC-No. 208-925-3 Reduced labelling (125 ml) Symbol(s): T Toxic
R-phrase(s): 25 Toxic if swallowed. S-phrase(s): 45 In case of accident or if you feel unwell, seek medical advice immediately (show the label where possible).
National legislation Storage class VCI: 6.1A Combustible substances, toxic
Major Accident Hazard Legislation: 96/82/EC Update: 2003 Toxic 2 Quantity 1: 50 t Quantity 2: 200 t
Other regulations: Take note of Dir 94/33/EC on the protection of young people at work. Take note of Dir 92/85/EEC on the safety and health at work of pregnant workers.
16. Other information Full text of R-phrases referred to under sections 2 and 3 R25 Toxic if swallowed.
Regional representation: This information is given on the authorised Safety Data Sheet for your country.
The information contained herein is based on the present state of our knowledge. It characterizes the product with regard to the appropriate safety precautions. It does not represent a guarantee of the properties of the product.