Professional Documents
Culture Documents
CUT HERE
1. FOLD HERE
1. FOLD HERE
Class B Airspace
Ref. FAR 91.131 and AIM 3-2-3
Description
Question: What if the controller puts me on a heading that will take me into the airspace, but doesnt actually tell me that Im cleared into the airspace?
cleared into the Class B airspace, or equivalent. If you dont, be sure to ask the controller before you enter the airspace.
Mode C Veil
Ref: AIM 3-2-3
Surrounds certain large airports Multiple segments with different ceiling/ floor altitudes. - Example: 70/30 = ceiling 7,000 msl, floor 3,000 msl
Description
Requirements/Limitations
M ode C veils exist within 30 nm of most Class B airports. (A list of these airports is available in FAR 91, Appendix D, Section 1) In some cases, Class B airspace extends beyond the Mode C veil
A TC clearance and establish two-way communication prior to entering Maintain two-way communication within Class B airspace Mode C transponder (inside the Mode C veil) Visibility: Three statute miles Cloud clearance: Clear of clouds Student pilot operations restricted
For more information, take ASIs Know Before You Go online course at www. airsafetyinstitute.org/kbyg.
Requirements/Limitations
2. CUT HERE
1. FOLD HERE
1. FOLD HERE
VFR Flyways
Ref. AIM 3-5-5
Description
U sed by ATC to route VFR traffic through Class B airspace Depicted on terminal area charts
Description
Requirements/Limitations
ATC clearance Mode C transponder Adherence to published route and ATC instructions
For more information, take ASIs Know Before You Go online course at www. airsafetyinstitute.org/kbyg.
A general flight path that helps pilots plan flights into, out of, through, or near complex terminal airspace to avoid Class B airspace ATC clearance not required
Answer: No. VFR flyways route you around Class B airspace. Remember, though, that they may take you through other areas with their own requirements (Class D airspace, for example).
For more information, take ASIs Know Before You Go online course at www. airsafetyinstitute.org/kbyg.
Requirements/Limitations
Mode C transponder Pilot must still comply with requirements for other airspace entered Depicted on the back of terminal area charts
2. CUT HERE
1. FOLD HERE
1. FOLD HERE
IFR Routes
Description
Ref: NACO Aeronautical Chart Users Guide O nly depicted on VFR terminal area charts Shows arrival and departure routes and altitudes of IFR traffic into and out of the terminal area of Class B airspace
Class C Airspace
Ref. FAR 91.130 and AIM 3-2-4
the VFR terminal area charts should alert VFR pilots operating in terminal areas of arriving or departing IFR traffic. Maintain extra vigilance when flying through or near these routes. For more information, take ASIs Know Before You Go online course at www. airsafetyinstitute.org/kbyg.
Description
Requirements/Limitations
Not applicable
Surrounds certain medium-sized airports Typically 10 nm radius Generally includes two segments: - 5 nm radius core from surface to 4,000 agl - 10 nm radius shelf from 1,200 to 4,000 agl
Question: Im departing from a small nontowered field three miles from the primary airport in Class C airspace. Am I required to contact ATC prior to takeoff? Answer: Generally, you are only
required to contact ATC as soon as practical after departure. However, you should follow any procedures specified in the Airport/Facility Directory: In many cases, you may be able to contact ATC from the ground.
2. CUT HERE
Requirements/Limitations
E stablish and maintain two-way communication prior to entering Mode C transponder Visibility: Three statute miles Cloud clearance: - 500 feet below - 1,000 feet above - 2,000 feet horizontal
2. CUT HERE
1. FOLD HERE
1. FOLD HERE
Class D Airspace
Ref. FAR 91.129 and AIM 3-2-5
Description
Surrounds smaller towered airports Typically 4 nm radius Ceiling generally 2,500 agl Usually reverts to a Class E surface area when the tower is closed May include Class E surface area extensions
Answer: Yes. Below 2,500 agl and within four nautical miles of the primary airport, aircraft are limited to 200 knots indicated airspeed.
2. CUT HERE
Description
For more information, take ASIs Know Before You Go online course at www. airsafetyinstitute.org/kbyg.
Requirements/Limitations
Requirements/Limitations
E stablish and maintain two-way communication Visibility: Three statute miles Cloud clearance: - 500 feet below - 1,000 feet above - 2,000 feet horizontal
Pilots are not required to participate Transponder and two-way communication for participating aircraft Rules for Class D airspace within apply regardless of pilot participation with TRSA radar services
Answer: TRSAs are leftovers from the previous (pre-1993) airspace classification system. As a general rule, they exist at airports where traffic load requires enhanced radar service, but that arent busy enough to justify Class C airspace.
For more information, take ASIs Know Before You Go online course at www. airsafetyinstitute.org/kbyg.
2. CUT HERE
1. FOLD HERE
1. FOLD HERE
Ref. FAR 91.127 and AIM 3-2-6(e)(1) A round some airports, Class E airspace begins at the surface, rather than the normal 700 or 1,200 agl Class D airports with part-time towers usually become Class E surface areas when the tower is not in operation
a Class D airport is closed, the airspacewhich is depicted with a dashed blue linemay revert to a Class E surface area. For more information, take ASIs Know Before You Go online course at www. airsafetyinstitute.org/kbyg.
Question: What purpose do Class E transition areas serve? Answer: Class E transition areas exist to help IFR traffic transition to or from the terminal or en route environment.
For more information, take ASIs Know Before You Go online course at www. airsafetyinstitute.org/kbyg.
Ref. FAR 91.127 and AIM 3-2-6(e)(3) Surrounds many nontowered airports Extends Class E airspace downward to accommodate IFR procedures
Requirements/Limitations
Below 10,000 msl: Visibility: Three statute miles Cloud clearance: - 500 feet below - 1,000 feet above - 2,000 feet horizontal
Requirements/Limitations
Below 10,000 msl: Visibility: Three statute miles Cloud clearance: - 500 feet below - 1,000 feet above - 2,000 feet horizontal
2. CUT HERE
1. FOLD HERE
1. FOLD HERE
Ref: NACO Aeronautical Chart Users Guide I dentifies different floor levels of airspace greater than 700 feet agl When the ceiling is less than 18,000 msl, the value, prefixed by the word ceiling, will be shown along the limits of the airspace boundaries
terrain (the Grand Canyon, for example), and off the east and west coasts of the United States. For more information, take ASIs Know Before You Go online course at www. airsafetyinstitute.org/kbyg.
Description
2. CUT HERE
Requirements/Limitations
Answer: Yes, but you are requested to maintain a minimum altitude of 2,000 agl whenever possible. This can also help you avoid bird strikes at low altitudes.
For more information, take ASIs Know Before You Go online course at www. airsafetyinstitute.org/kbyg.
P ilots are requested to avoid flight below 2,000 agl in these areas
Requirements/Limitations
Not Applicable
2. CUT HERE
1. FOLD HERE
1. FOLD HERE
Prohibited Area
Ref. AIM 3-4-2
Question: How much distance should I maintain from prohibited areas? Answer: You should steer well clear of prohibited areas. Allow at least a few miles to account for navigation error and variances between GPS and ATC radar positions.
For more information, take ASIs Know Before You Go online course at www. airsafetyinstitute.org/kbyg.
Restricted Area
Ref. AIM 3-4-3
Description
Description
Answer: Yes, but you should be certain to contact the controlling ATC facility for current status before entering the airspace.
For more information, take ASIs Know Before You Go online course at www. airsafetyinstitute.org/kbyg.
Requirements/Limitations
Requirements/Limitations
2. CUT HERE
V FR flight through an active restricted area is not permitted without prior permission Check with the controlling ATC facility (noted on sectional charts) for current status prior to entering
2. CUT HERE
1. FOLD HERE
1. FOLD HERE
Warning Area
Ref. AIM 3-4-4
Alert Area
Ref. AIM 3-4-6
Question: Do I need to contact ATC prior to entering an alert area? Answer: No. ATC contact/clearance is not required to enter an alert area.
For more information, take ASIs Know Before You Go online course at www. airsafetyinstitute.org/kbyg.
Description
Extends outward from 3 nm off the coast Warns pilots of potentially hazardous activities
the controlling ATC facility for status information prior to entry. Active warning areas can be dangerous to general aviation aircraft. For more information, take ASIs Know Before You Go online course at www. airsafetyinstitute.org/kbyg.
Description
E stablished in areas with a high volume of pilot training or unusual type of aerial activity
2. CUT HERE
Requirements/Limitations
Requirements/Limitations
2. CUT HERE
1. FOLD HERE
1. FOLD HERE
Description
Answer: High-speed flight, aerobatic maneuvers, and low-level flight can all be expected. In certain MOAs, lights out night training is also permitted.
2. CUT HERE
route?
Description
Requirements/Limitations
V FR pilots may fly through active MOAs, but are advised to exercise extreme caution Pilots should check with the controlling ATC facility (noted on sectional charts) for MOA status prior to entering an MOA
For more information, take ASIs Know Before You Go online course at www.airsafetyinstitute.org/kbyg and ASIs Mission: Possible course at www. airsafetyinstitute.org/mission_possible. Also, view ASIs Lights-Out safety advisor at www.aopa.org/asf/publications/sa21.pdf
M TRs prefixed with the letters IR are for IFR flights MTRs prefixed with the letters VR are for VFR flights MTRs with a letter suffix (i.e., A, B, etc.) denote an alternate route MTRs with four numbers denote routes flown at 1,500 agl and below MTRs with three numbers denote routes with at least one segment above 1,500 agl
or MTR, is used by the military for conducting low-altitude, high-speed flight training. Typically the routes above 1,500 agl are flown under IFR, and the routes below 1,500 are flown under VFR. Contact Flight Service for MTR activity that might affect your route of flight. For more information, take ASIs Know Before You Go online course at www. airsafetyinstitute.org/kbyg.
Requirements/Limitations
2011 Air Safety Institute www.airsafetyinstitute.org
2. CUT HERE
1. FOLD HERE
1. FOLD HERE
Question: Where might I expect to find an NSA? Answer: NSAs can be established anywhere a need for greater security exists, but are most often seen around government/military installations.
2. CUT HERE
Description
Ref. Part 91 Special Federal Aviation Regulations (SFARs) D epicts airspace subject to special regulation - Examples: Grand Canyon, Washington, D.C. area
Answer: Procedures vary. In the Grand Canyon, for example, special transition routes and altitude rules apply.
Requirements/Limitations
P ilots are requested to avoid flight below a specified altitude within the NSA Flight may be temporarily restricted or prohibited by notam
For more information, take ASIs Know Before You Go online course at www. airsafetyinstitute.org/kbyg.
Requirements/Limitations
As specified by SFAR For operating rules, refer to the chart legend or the SFAR section at the beginning of FAR Part 91 2011 Air Safety Institute www.airsafetyinstitute.org 2011 Air Safety Institute www.airsafetyinstitute.org
2. CUT HERE
1. FOLD HERE
1. FOLD HERE
Description
enter the Washington, D.C. SFRA, do I also have permission to enter the Class B airspace within?
3 0 nm radius of the DCA VOR/DME Speed restriction ring 30 to 60 nm radius of the DCA VOR/DME Surface up to but not including FL180 ctive IFR or D.C. SFRA flight plan A Two-way radio communication Discrete transponder code (Mode C) Enter and exit via specific gates 180 KIAS or less in the D.C. SFRA, if able 230 KIAS or less in the 30 to 60 nm speed restriction ring, if able Refer to www.aopa.org/security for additional information Before operating within 60 nm of the D.C. SFRA, pilots must complete FAAs online training course
Answer: No. You need a specific clearance to enter the Class B airspace.
For more information, take ASIs Know Before You Go online course at www.airsafetyinstitute.org/kbyg.
Description
2. CUT HERE
Answer: Yes. Before flying into the FRZ, you must undergo a background check and follow special procedures.
For more information, take ASIs Know Before You Go online course at www. airsafetyinstitute.org/kbyg.
Requirements/Limitations
Requirements/Limitations
G eneral aviation flights are prohibited with limited exceptions Refer to www.aopa.org/security for additional information
2. CUT HERE
1. FOLD HERE
1. FOLD HERE
plan, and why is one required for VFR aircraft that enter the contiguous U.S. ADIZ?
Description
Description
2. CUT HERE
M ost TFRs are not charted, although some longer-term TFRs are
Requirements/Limitations
As specified by notam
Requirements/Limitations
IFR or DVFR (Defense VFR) flight plan Discrete transponder code (Mode C) DVFR aircraft must make position reports prior to entering Two-way radio communication 12 N-numbers
Answer: A normal VFR flight plan is not transmitted to ATC: It exists for search-and-rescue purposes only. A DVFR (Defense VFR) flight plan is transmitted to ATC, letting controllers know that the aircraft will be approaching an ADIZ under VFR.