You are on page 1of 6

Project: Sliding bevel square

Page 1 of 6

Sliding bevel square

A sliding bevel square, which is an essential tool for marking out dovetails and other joints with angles, can be made on the same lines as the try square . Again the dimension given are only for guidance.

Project: Sliding bevel square Parts list

Page 2 of 6

Project: Sliding bevel square Assembly drawing

Page 3 of 6

Project: Sliding bevel square 1. Stock

Page 4 of 6

Project: Sliding bevel square 2. Straight Edge

Page 5 of 6

Project: Sliding bevel square Standard parts

Page 6 of 6

Assemblage instructions
1. Mark a central point 20mm from the end of the stock and drill a D6mm hole. Fit the straight edge into the socket.

2.

Pass the screw through this hole and the two washers and tighten the wing nut.

You might also like