Professional Documents
Culture Documents
Introduction
This notice updates the TransWin program from version 3.1 to version 3.3. TransWin 3.3 is a product of continuing development from Doble Engineering, as well as valued input of our customers.
CD-ROM Drive (unless the program is downloaded directly from the Doble Engineering web site). An available Serial Port in the PC or UBS port, 10Base2 Network card with BNC Connector (F6150 CPU1), or 10BaseT (or 10/100) Network card with RJ45 Connector (F6150 CPU2). Serial cable, Ethernet RG58 BNC cable with 50 Ohm terminators (F6150 CPU1 only), Ethernet Cat5 cable (F6150 CPU2 only). An Ethernet Cat5 crossover cable will be required for F6150 CPU2 instruments with single RJ45 interface on front panel. The F6150 or F6150A firmware should be 2.23 or newer for CPU1 and 4.27 or newer for CPU2 instruments. AIM (Analog Input Measurement) board has to be installed in F6150 if recording is desired.
Limitations
Transition delay edit box won't accept default values after editing. Remove assigned trigger (select None from the drop-down menu) and reassign trigger to get zero transition delay.
Installation
If you have a CD, insert the CD into the CD-ROM drive. On Windows task bar, select Start Run. If D: is the CD-ROM drive letter, type D:\Transwin 3.3\Setup.exe. Or use the Browse button to locate the setup.exe file. Press Enter or click OK. This will launch TransWin 3.3 Installation Wizard. Follow the instructions. You may also download TransWin 3.3 from Doble website or ftp site and run setup.exe.
Contact Us
Should you have any questions regarding this TransWin release or any other Doble Engineering Company protective relay testing product please contact us at: Ph: US +1 617 926 4900 Fax: US +1 617 926 0528 E-Mail: fserieshelp@doble.com