You are on page 1of 29

GET/ISG/MUK/231/2012-2013 November 30, 2012

M/s. MUKESH ASSOCIATES SALEM,

Kind Attn.
Dear Sir, Subject treatment Plant :

Mr. Chandrahasan

Techno commercial offer of Effluent

We thank you for your enquiry towards Design, Supply, Erection and Commissioning of above Effluent Treatment Plant. With reference to your enquiry, we are pleased to enclose our Techno Commercial offer for the same. In case should you desire to have any clarifications please feel free to contact us. Thanking you and assuring you of our best services at all times. Yours Faithfully, For G.E.T WATER SOLUTIONS PRIVATE LIMITED

CYRIL GUBBI DIRECTOR TECHNICAL MANAGER

R.JAYACHANDRAN REGIONAL

EFFLUENT TREATMENT PLANT FOR MUKESH ASSOCIATES

Page 1

MOBILE: +91 98400 46768

MOBILE-9383221017

INDEX
SECTION
1. COMPANY INTRODUCTION LETTER 2. DESIGN BASIS & TREATED WATER QUALITY 3. PROCESS DESCRIPTION OF SYSTEM

4. TECHNICAL SPECIFICATION OF PLANT 5. INTERCONNECTING PIPINGS & INSTRUMENTATION 6. SCHEDULE OF EXCLUSIONS 7. COMMERCIAL TERMS & CONDITIONS

ETP FOR MUKESH ASSOCIATES

Page 2

SECTION 1 COMPANY PROFILE


We would like to introduce ourselves as one of the leading Designers, and Consultants on Environmental Aspects and OE manufacturers of Water, Waste Water, Effluent Treatment Plants, Zero discharge plants and seawater desalination plants. GET has an experienced and motivated team of Professionals in Design, Engineering, Execution and Project Management of different capacities of Water Treatment Plants, Effluent Treatment Plants, Effluent Recycling Plants, Sewage Treatment Plants, Zero discharge plants and sea water desalination plants. G.E.T specializes in varied membrane technology using Ultrafiltration, Nanofiltration, Membrane Bio Reactors and advanced technology like electro oxidation, EDI, Metal recovery by resins etc. Some of the industrial verticals served by G.E.T are Steel, Cement, Paper & Pulp, Power, Pharma, Textile, and I.T Parks etc. We have been approved by Leading Consultants such as SPB Consultants Chennai, Avant Garde Consultants Chennai, Fitchner Consultants Chennai, Potential Service Consultants Bangalore, Jurong Consultants, Prism Consultants Bangalore, ESKAY Associates, Thyssen Krupp, FL Smidth, Befesa Spain, CRN, CCCL, IVRCL, Spectral, etc.
ETP FOR MUKESH ASSOCIATES Page 3

We would like to inform you that we have executed Sea Water DeSalination Plants, Reverse Osmosis Plants, and De Mineralization plants apart from regular Water Treatment Plants such as Softeners, Pressure Sand Filters, Activated Carbon Filters and Iron Removal Filters of varying Capacities meeting to the process requirements of the Industries.

TEXTILE INDUSTRY:

We have executed Effluent Treatment Plants to various Textile/Apparel Industries such as S.P.Tex Fab Limited (700 KLD), Shivashakti Fashions (250 KLD), Perfect Knitters Limited, Indusfila Mysore (2000 KLD), Jay Jay Mills Erode (700 KLD), RBR Garments Tirupur (700 KLD) to name a few. The above plants uses electro-oxidation technology followed

Ultrafiltration, Nanofiltration and RO systems.

ETP FOR MUKESH ASSOCIATES

Page 4

PAPER & PULP INDUSTRY:

We have successfully executed an Export order from a Paper Mill, Dubai for supply of 75 cum/hr Ultrafiltration system as pretreatment to RO plant. This plant uses the Secondary treated effluent of Dubai Municipality.

ETP FOR MUKESH ASSOCIATES

Page 5

PHARMA INDUSTRY:

We have also installed the Water Treatment Plants to Pharmaceutical Industries such as M/s Srini Pharmaceuticals Limited, Hyderabad, M/s. Shasun Chemicals and Drugs Ltd., Pondicherry, Hetero Drugs Limited & Hetero labs Ltd. This plant consists of pretreatment, RO plant and DM plant.

ETP FOR MUKESH ASSOCIATES

Page 6

AUTOMOBILE INDUSTRY:

We have executed Sewage treatment plant at Delphi TVS and also doing the Operation and Maintenance of an effluent recycling plant at Brakes India, Padi. This Plant consists of Secondary clarifier, tertiary treatment plant, Ultrafiltration plant, Primary & Secondary RO plant.

ETP FOR MUKESH ASSOCIATES

Page 7

MINERALS & STEEL INDUSTRY: We have a supplied a Water Treatment Plant for Jindal steel and for Sai Krishna Minerals. These plants consist of Pretreatment, RO and Post treatment consisting of UV and Ozonator.

ETP FOR MUKESH ASSOCIATES

Page 8

WAFER & SEMI CONDUCTOR INDUSTRY:

G.E.T has executed both Water treatment plant and Sewage treatment to Nokia, Flextronics, Motorola, Dell etc.

ETP FOR MUKESH ASSOCIATES

Page 9

SEA WATER DESALINATION PLANTS:

Currently G.E.T is executing a prestigious order from Befesa/ IVRCL for the Fabrication of RO Racks for their 100 MLD Desalination plant at Minjur. RO Racks is under erection at Minjur site.

MEMBRANE BIO REACTORS:

G.E.T also specializes in the latest state of art Technology MBR and is now currently executing projects at Bangalore International Airport and

ETP FOR MUKESH ASSOCIATES

Page 10

Infosys. This technology uses immersed hollow fibre membranes for treating sewage effluents.

Apart from this, G.E.T has a captive fabrication facility at Kakkalur Sidco Industrial Estate, which is approx. 45kms from Chennai and 2 kms from Thiruvellur Railway station and is on the NH 205 highways. The covered area of the fabrication shop is 13000 sq.ft with the shed size of 285ft x 45ft x width x 18ft high. The total shed is situated on a 4.5-acre land and adequate open space for material yard and heavy fabrication items. This unit is covered under SSI unit. We have so for handled the following

JOBS HANDLED Sand filters Activated Carbon filters

ETP FOR MUKESH ASSOCIATES

Page 11

Softeners DM Plants Atmospheric Tanks Bulk storage tanks Dosing Tanks RO Skid Fabrication UF Skid Fabrication Clarifier Mechanism Reactors

MATERIAL HANDLED

Mild steel Mild Steel with Rubber lined. Stainless steel SS 304/316/316L

INSPECTION AGENCY We can liaison with any agencies for the job certification and fabrication will be done as per your Quality Assurance Plan and your drawings.

ETP FOR MUKESH ASSOCIATES

Page 12

SECTION 2 DESIGN BASIS & TREATED WATER QUALITY


CHARACTERISTICS OF RAW WATER: We have considered the following parameters to design the above system. Any changes in the water quality will affect the plant performance. Sl No Parameters 1. 2. pH TDS mg/l Unit Design Concentration 7.2 7000

Note: the above valves are assumed for the Design of Effluent Treatment Plant TREATED WATER QUALITY (OUTLET OF RO) Sl No Parameters 1. 2. pH TDS mg/l Unit Design Concentration 4.9 <20

ETP FOR MUKESH ASSOCIATES

Page 13

SECTION 3 TECHNICAL SPECIFICATION OF ENTIRE SYSTEM


BAR SCREEN CHAMBER Quantity MOC 1 No MSEP

COLLECTION CUM EQUALIZATION TANK Quantity Capacity MOC 1 No 240 m3 RCC (Client Scope)

RAW WATER TRANSFER PUMP Quantity Capacity Head Type MOC Make 2 Nos(1W + 1S) 60 m3/hr 30 mtr Horizontal Centrifugal CI Kirloskar/Johnson/Equiv

CLARIFLOCCULATOR MECHANISMS Quantity capacity Retention time Diameter Height MOC of mechanism MOC of tank 1 No 175 m3 3 hrs 8m 3.5 m SWD MSEP RCC (client scope)

ETP FOR MUKESH ASSOCIATES

Page 14

ALUM DOSING SYSTEM Pump Quantity Dosing flow range Pressure Type MOC Make Tank Qty Dosing Tank MOC

1 No 240 LPH 4 Kg/cm2 Diaphragm PP Positive/Milton roy/Equivalent 1 Nos. 2000 Ltrs, HDPE

CAUSTIC DOSING SYSTEM Pump Quantity Dosing flow range Pressure Type MOC Make Tank Qty Dosing Tank MOC

2 Nos (1w + 1s) 3 LPH 4 Kg/cm2 Diaphragm PP Positive/Milton roy/Equivalent 1 Nos. 50 Ltrs, HDPE

LIME DOSING SYSTEM Pump Quantity Dosing flow range Pressure Type
ETP FOR MUKESH ASSOCIATES

2 Nos (1w + 1s) 240 LPH 4 Kg/cm2 Diaphragm


Page 15

MOC Make Tank Qty Dosing Tank MOC

PP Positive/Milton roy/Equivalent 1 Nos. 2000 Ltrs, HDPE

POLY DOSING SYSTEM Pump Quantity Dosing flow range Pressure Type MOC Make Tank Qty Dosing Tank MOC

2 Nos (1w + 1s) 6 LPH 4 Kg/cm2 Diaphragm PP Positive/Milton roy/Equivalent 1 Nos. 200 Ltrs, HDPE

CLARIFIED WATER STROAGE TANK Quantity Capacity MOC FILTER FEED PUMP Quantity Capacity Head Type MOC
ETP FOR MUKESH ASSOCIATES

1 No 120 m3 RCC (Client Scope)

2 Nos(1W + 1S) 60 m3/hr 30 mtr Horizontal Centrifugal CI


Page 16

Make

Kirloskar/Johnson/Equiv

PRESSURE SAND FILTER Quantity Capacity Diameter Height Filtering media MOC 1 No 60 m3/hr 2400 mm dia 1500 mm HOS Sand/Pebbles MSRP

ACTIVATED CARBON FILTER Quantity Diameter Height Filtering media Backwash duration MOC 1 No 2400 mm dia 1800 mm HOS Sand/Pebbles Once in 8 hrs MSEP

FILTERED WATER STROAGE TANK Quantity Capacity MOC UF FEED PUMP Quantity Flow Rate Head Type MOC Make UF FEED STRAINER Quantity Flow rate Material of Construction Micron Rating Make 2 Nos(1W + 1S) 60 m3/hr SS 316 100 Microns Gopani/Eqv 2Nos.(1W+1S) 60 m3/hr 15 mwc Horizontal Centrifugal SS304 Johnson/Kirloskar/Eqvt 1 No 120 m3 RCC (Client Scope)

ETP FOR MUKESH ASSOCIATES

Page 17

UF MEMBRANE Type of Membrane MOC Of Membrane MOC of Housing Flow Operating Pressure Trans Membrane Pressure Operating pH Operation Mode Membrane Area Make Quantity UF BACKWASH PUMP Quantity Flow rate Pressure of Operation Type of Pump Material of Construction Accessories Make UF SKID SYSTEM Skid is fabricated with MS and painted with two coats of paint. Pump with motor on a common base plate shall be mounted on the skid with proper base. Structural support member and rubber padding to reduce the pump vibration. Piping and fittings firmly secured to the skid through clamps. Quantity 1 Set UF PERMEATE WATER STORAGE TANK 2 Nos (1W+1S) 170 m3/hr 3.0 kg/cm2 Horizontal Centrifugal Pump SS 316 Base Plate, NRV, Valves Etc., Johnson/KSB/Sulzer/Eqv Hollow Fibre PES uPVC IN - OUT 3.5 Kg/cm2 2.0 Kg/cm2 1 - 13 Cross Flow/Dead end 1000m2 Hydranautics/Toray/Koch/E qvt 10 nos

Quantity Offered Volume of Tank


ETP FOR MUKESH ASSOCIATES

1 No. 100 m3
Page 18

Material of Construction

RCC (Client Scope)

ACID/CAUSTIC DOSING PUMP & TANK


Quantity

Flow rate Pressure of Operation MOC of Dosing Pump Accessories Type of Pump Make DOSING TANK Capacity of Tank Material of Construction Quantity

2 Nos(1W+1S) 130 LPH 3.5 Kg/cm2 PP Foot Valve, Dosing Valve Etc., Diaphragm, Motor Driven Type Milton Roy/Sandur/Eqv 1000 Ltrs HDPE 1 No.

HYPO DOSING PUMP & TANK


Quantity

Flow rate Pressure of Operation MOC of Dosing Pump Accessories Type of Pump Make DOSING TANK Capacity of Tank
ETP FOR MUKESH ASSOCIATES

2 Nos(1W+1S) 340 lph 3.5 Kg/cm2 PP Foot Valve, Dosing Valve Etc., Diaphragm, Motor Driven Type Milton Roy/Sandur/Eqv 2000 Ltrs
Page 19

Material of Construction Quantity

HDPE 1 No.

RO SYSTEM ANTISCALANT DOSING SYSTEM Pump Quantity Dosing flow range Pressure Type MOC Make Tank Qty Dosing Tank MOC SMBS DOSING SYSTEM Pump Quantity Dosing flow range Pressure Type MOC Make Tank Qty Dosing Tank MOC

1 No 6 LPH 4 Kg/cm2 Diaphragm PP Positive/Milton roy/Equivalent 1 Nos. 100 Ltrs, HDPE

1 No 6 LPH 4 Kg/cm2 Diaphragm PP Positive/Milton roy/Equivalent 1 Nos. 100 Ltrs, HDPE

ETP FOR MUKESH ASSOCIATES

Page 20

HCL DOSING SYSTEM Pump Quantity Dosing flow range Pressure Type MOC Make Tank Qty Dosing Tank MOC

1 No 3 LPH 10 Kg/cm2 Diaphragm PP Positive/Milton roy/Equivalent 1 Nos. 100 Ltrs, HDPE

MICRON CATRIDGE FILTER Numbers Offered Flow Rate Micron Rating MOC of Housing Make 1 No. 54 m3/hr 5 Micron SS304 Gopani

RO HIGH PRESSURE PUMP Numbers Offered Flow Rate Head MOC Make 2 Nos (1w+1s). 54 m3/hr 325 mts SS304 Grundfos/Eqvt

ETP FOR MUKESH ASSOCIATES

Page 21

RO I BLOCK Number of Skid Feed Flow Rate Permeate Flow Rate Reject Flow Rate RO Recovery Type of membrane Membrane Size Make No of Membranes Membrane Housing Make Operating Pressure 1 No 54 m3/hr 40.5 m3/hr 13.5 m3/hr 75 % SWC5-LD 8dia X 40 Length Hydranautics /GE/ Equivalent 54 Nos 9 Nos (6 Element Long) Codeline /Advance composite/ Equi 600 PSI

RO II BOOSTER PUMP Numbers Offered Flow Rate Head MOC Make 2 Nos (1w+1s). 13.5 m3/hr 620 mts SS316 Grundfos/Eqvt

ETP FOR MUKESH ASSOCIATES

Page 22

RO II BLOCK Number of Skid Feed Flow Rate Permeate Flow Rate Reject Flow Rate RO Recovery Type of membrane Membrane Size Make No of Membranes Membrane Housing Make Operating Pressure CIP TANK Numbers Offered Capacity MOC Make CIP PUMP Numbers Offered Capacity Head MOC Make 1 No 60 m3/hr 35 mts SS316 Kirloskar / Eqv 1 No. 5000 Ltrs HDPE Sintex/Equivalent 1 No 14 m3/hr 7 m3/hr 7 m3/hr 50 % SWC5-LD 8dia X 40 Length Hydranautics /GE/ Equivalent 10 Nos 2 Nos (5 Element Long) Codeline /Advance composite/ Equi 1000 PSI

ETP FOR MUKESH ASSOCIATES

Page 23

CIP MICRON CATRIDGE FILTER Numbers Offered Flow Rate Micron Rating MOC Make RO REJECT TANK Numbers Offered Capacity MOC 1 No 28 m3 RCC (Client scope) 1 No. 4 m3/hr 5 SS316 Gopani/ Eqv

TREATED WATER STROAGE TANK Quantity Offered Volume of Tank Material of Construction MCC PANEL Material of Construction MS Fabricated & Painted All Electrical Inputs, 1 Lot Output, Motor Control Panel, Control panel for Instrumentation Including accessories, Wiring etc., ELECTRICAL CABLING & TRAYS 1 LOT Interconnecting cabling 1 Lot 1 No. 190 m3 RCC (Client Scope)

between Panel and Pump within the WTP Area

SECTION 5 INTERCONNECTING PIPINGS & INSTRUMENTATION


ETP FOR MUKESH ASSOCIATES Page 24

INTERCONNECTING PIPING & FITTINGS S NO 1. 2. 3. DESCRIPTION uPVC Piping & Fittings for Low Pressure lines uPVC Piping & Fittings for Interconnecting Pipes RO high pressure line SS 304 QTY 1 Lot 1 Lot 1 Lot

INSTRUMENTATION LIST S NO 1. 2. 3. 4. 5. 6. 7. 8. 9. 10 . 11 . DESCRIPTION Pressure Gauges for all Pumps Pressure Gauges at Filters Flow meter at Filter Inlet Flow Meter at UF Inlet Flow Meter at RO Inlet Electromagnetic Flow Meter Permeate Flow Meter at RO I Reject Electromagnetic Flow Meter Permeate ORP Meter at RO Inlet Conductivity Meter at RO Outlet pH Meter at RO Inlet & Outlet QTY 1 Lot 1 Lot 1 Lot 1 Lot 1 Set. 1 Lot 1 No. 1 No 1 No 1 No 1 No

at

RO

at

RO

II

SECTION 7 SCOPE OF EXCLUSIONS


ETP FOR MUKESH ASSOCIATES Page 25

SCOPE OF EXCLUSIONS All Civil works including foundations of electromechanical

equipments, any other civil related works is excluded from our scope of supply. All other piping and electrical works beyond battery limit is excluded. Water and Power required for E&C are to be supplied at free of cost. Storage of material at site before commissioning of plant shall be client scope Water at required Quantity and Quality. Third Party Inspection. Main cable to our panel board and earthing arrangement shall be client scope 24 x 7 Power supply Drainage System RO System Building\Shed Walkways, Operating Platform & Access ladders. Roads, Fences and all other ancillary civil works. Drainage system for buildings including sanitary wastewater & Laboratory etc. Earth Pit and below ground earthing Equipment lighting, Area lighting and indoor lighting system with fan points. Trenches and supports for piping and electrical

ETP FOR MUKESH ASSOCIATES

Page 26

SECTION 8 COMMERCIAL TERMS & CONDITIONS


PRICE SCHEDULES SL NO 1. ITEM DESCRIPTION AMOUNT (RS)

The Price for Supply of Water Treatment Plant Erection system & Commissioning of above

Unpriced bid

2.

Unpriced bid

NOTE: Order to be placed as per the description mentioned above We request you to issue your orders in two formats; one as purchase order for supply of components and the other as work order for erection & commissioning.
PRICE BASIS

S. No. 1. 2. 3. 4. 5. 6. Note

Commercial Terms
VAT Applicable for sales within Tamilnadu) Extra

Commercial Data

Excised duty Service tax Freight Insurance Unloading at site

Not applicable. Extra at Actuals.


Included

Extra at Actuals. Included

Should there be change in ED, VAT and CST at the time of dispatch the same shall charged to customers account.

ETP FOR MUKESH ASSOCIATES

Page 27

PAYMENT TERMS & CONDITIONS A) SUPPLY OF ELECTRO MECHANICAL EQUIPMENTS SL NO 1. 2. 3. 4. PAYMENT TERMS 30% 60% 5% 5% Commercial Data Advance along with your purchase order. Against Pro-forma Invoice before dispatch. Against erection (or) 30days from the date of supply. Against commissioning (or) 60 days from the date of supply. b) ERECTION & COMMISSIONING SL NO 1. 2. 3. PAYMENT TERMS 90% 5% 5% Commercial Data Advance along with your purchase order. Against Completion of erection work Against Completion of commissioning work. Warranty: 24 months from the date of commissioning or 18 months from the date of delivery whichever is earlier against inherent manufacturing defects. This warranty does not cover any electrical or electronic items and any replacement for normal wear and tear. Time Schedule: The equipment under our scope of supply shall be delivered and completed within 10 - 12 weeks from the date of receipt of firm technically and commercially clear order along with advance. Plant erection & startup shall be 6 - 8 weeks from date of supply of equipments. Validity: Our proposal is valid for a period of 30 days for your acceptance after which it is subject to our confirmation.

ETP FOR MUKESH ASSOCIATES

Page 28

Thanking You, Yours Faithfully, For G.E.T. WATER SOLUTIONS PRIVATE LIMITED CYRIL GUBBI DIRECTOR TECHNICAL MANAGER MOBILE: +91 98400 46768 R.JAYACHANDRAN REGIONAL MOBILE-9383221017

ETP FOR MUKESH ASSOCIATES

Page 29

You might also like