Professional Documents
Culture Documents
Faculty of Engineering and Technology, SRM University DESIGN PROJECT PROPOSAL FORM
Project Title
: A Wireless Data Acquisition and Transmission System Design : Mrs. V. Sarada Assistant professor Electronics and Communication Department : 1. Inderpal Singh (Reg No.- 10407077) 2. Mohit Kumar (Reg No.- 10407101) 3. Mohit Sharma (Reg No.- 10407102)
Supervisor/Guide
Team Members
Background/Literature Review: This paper presents the design proposal of hardware and software of information terminal (a machine) and wireless receiver module of multi-point short-range wireless data collection and transmission network, which provides a low-powered, low cost and high-performance wireless data communication system. References: 1. 2009 First International Workshop on Education Technology and Computer Science Cai Jun; Liu Jing-li; Dept. of Electr. & Commun. Eng., Sun Yat-Sen Univ., Guangzhou 2. Shijin Dai, Xiaorong Jing and Lemin Li, Research and analysis on routing protocols for wireless sensor networks, 2005 International Conference on Communications, Circuits and Systems, Vol. 1, 27-30, May 2005. 3. Dacfey Dzung, Mario Crevatin, Security for Industrial Communication Systems, 2005 Proceedings of the IEEE.
Objective: To implement Data Acquisition is mainly to collect the real time parameters and to monitor if it exceeds the pre-defined value. Requirements: 1) Power supply[5v] 1
2) PIC 16F877A microcontroller evaluation board 3) Temperature sensor 4) Humidity sensor 5) Max232 serial communication 6) ZIGBEE Transceiver 7) Mplab IDE and VISUAL BASIC. 8) Flash Programmer 9) Language: Embedded C 10) Orcad Tool Technical Requirements: To be written appropriately Engineering standards and realistic constraints in these areas:
Area
Economic Environmental Social Ethical Health and Safety Manufacturability
Sustainability
Realistic Constraints: 1.) Despite improved security measures it still may be vulnerable to advanced security threats. 2.) Despite high cost it is more cost effective than systems using CDMA etc. 3.) Speed is high. Deliverables: 1) A prototype DATA ACQUISITION will be constructed. 2) PCB of control and demonstration of data acquisition. 3) Software interface with Mplab and Visual Basic. 2
Standards Referred/used: 1) RS232C- Serial Communication 2) IEEE 802.15.4- ZigBee 3) IS 12970- Semiconductor devices Integrated circuits Abstract: In modern wireless communication, GSM, CDMA, 3G, and Wi-Fi become the mainstream solution of wireless data transmission network because of their high speed and reliable quality. They also have the shortcomings of high cost, so wider application would cause a great waste of resources, and they cannot be promoted in small regional, low speed data communications. This paper presents the design proposal of hardware and software of information terminal (a machine) and wireless receiver module of multi-point short-range wireless data collection and transmission network, which provides a low-powered, low cost and highperformance wireless data communication system, works in the ISM (Industrial Scientific Medical Band.
Fig.
Transmitter side
Fig. Receiver side Additional Requirements: (Multidisciplinary tasks Mechanical, instrumentation, electrical, Computational /IT involved) This project involves lot of mechanical design including the design of Robotic tank base and the arms. Tank base structure to be used is for more stability.
Other Department Basic Sciences Mechanical Engineering Instrumentation and Control Engineering Electrical and Electronics Engineering Computational/IT Biomedical Engineering Purchase Section Maintenance Department Desktop publications
Utilised for
Remarks
Report