Professional Documents
Culture Documents
Subsidiaries
I Associates
CIRCULARS
Minor Irrigation Land Development Plantation / Horticulture Agricultural Engineering Forestry / WasteLand Fisheries Animal Husbandry Medicinal & Aromatic Plants Biotechnology State Specific Projects Organic Farming
Model Bankable Projects Animal Husbandry Calf Rearing 1. Introduction Investment Credit This is a longterm refinance facility, it is intended for Investment in agriculture and allied activities Technical Services Department This division is the service provider on technical issues
Banks have been focussing mainly on financing of milch animals under various government sponsored programmes and dairy activities. Many bankers have felt that this has not led to any increase in milk production but has only ensured transfer of assets already created. The demand for good quality animals has gone up. It is high time that banks shift their focus to calf rearing and cattle breeding schemes so that better animals can be made available to the dairy sector. Calf rearing scheme has not been popular among farmers also for a number of reasons like its long gestation period, disbursement being made over a period of 2 years in small amounts and unwillingness of the farmer to take up such a long term activity. Normally, when a cow is purchased under a bank loan, a calf at foot (of one month age) is also purchased along with the cow. Half of such calves are females and can be grown as quality cows if they are cross bred. Since borrowers are financed for a minimum of 2 cows with a gap of 6 months in between, most of the farmers will have at least one female cross bred calf which can be covered with the proposed scheme. 2. Selection of beneficiary and location: Genuine farmers interested in dairy activity can be covered under the scheme. Cross breeding is popular throughout the country and in many places cross bred cows only are purchased under bank schemes. Even though dairying is a traditional activity in our country it is important that the banks ensure that the farmers are trained well in calf rearing before finance is made available. It is possible to finance calf rearing scheme as a separate activity also especially in areas where fodder production is well established. Cost of calf rearing can be brought down substantially , if fodder cultivation under irrigated condition is also financed along with this activity. Hilly terrain where regular milk collection is a problem is more suitable for this activity. In case of large farms, breeding schemes can be formulated where high quality semen is used over the animals with the help of liquid nitrogen storage flasks. However, even a small dairy farmer can be encouraged to go in for calf rearing as the space requirement and other help needed will be minimal for this activity. Under the present scheme a model is suggested for financing a single female calf wherever two animals are being financed to the farmer. The scheme can be suitably modified to finance the calf of the second animal is the female calf or enhanced if both calves are crossbred females. 3. Techno economic parameters of the Scheme:
(a) The performance of any individual animal is dependent on its genetic potential and the environment. Cross breeding has increased the yield potential of our cows but many of these cows are unable to express their full potential for milk production due to poor growth and nutrition. (b) Growth phase of the cows is confined to the first two years of its life. It is important that the calf is given nutritious feed in the form of concentrates or fodder right from its 4th month of age. This will ensure good milk yielf when the calf becomes a cow. The age at which feeding starts naturally becomes important and it is recommended that right from the 4th month of age concentrate feed should be made available to he calf. If the animal is introduced into the feeding schedule after the 6 month of age the desired effect may not be to the full extent. The calf , depending upon its body weight/breed will consume around 1600 kgs of concentrate . This amount can be substantially reduced if good quality fodder is available. On an average it is assumed that the calf will come to puberty around 20-24 months of age and will become a cow by calving for the first time around 28-38 month of age, if managed properly. 4. Capital Cost: For a 2 animal dairy unit, additional provision towards feeding of the calf is the only item of expenditure given under the scheme. However, in case of large schemes , separate provisions like sheds for the calves, fodder cultivation, etc. can be considered. As a dairy farmer will have running relationship with the bank, disbursement of money towards concentrate feed requirement of the calf or disbursement in kind may not be a problem.A capital cost of Rs.Rs.33250 is indicated as per details enclosed and it can be suitable changed to suit local unit cost and requirements. 5.Economics of the Scheme: Details of lactation cycle and cash inflow and expenditure are indicated in the following statement. It may be seen from the same that calf can be sold as a lactation cow during the third year and income can be used for repaying the loan. The IRR works out to be more than 50% and repayment schedule is also fixed for a period of 5 years by assuming that 60% of the income generated will be used towards repayment of principal and interest. 6.Sanction of Bank Loan and its Disbursement After ensuring technical feasibility and economic viability, the scheme is sanctioned by the bank. The loan is disbursed in stages against creation of specific assets such as construction of sheds, purchase of equipments and animals. The end use of the loan is verified and constant follow-up is done by the bank. 7.Lending Terms - General 7.1 Unit cost Each regional office (R.O.) Of NABARD has constituted a State Level Unit Cost Committee under the chairmanship of RO-in-charge and with the members from developmental agencies, commercial banks and cooperative banks to review the unit cost of various investments once in six months. The same is circulated among the banks for their guidance. 7.2 Interest Rate for ultimate borrowers Banks are free to decide the rate of interest within the overall RBI guidelines. However for working out financial viabilility and bankability of the model project we have assumed the rate of interest as 12% p.a. 7.3 Margin Money NABARD has defined the farmers into three different categories and where subsidy is not available the minimum down payment to be contributed by the
beneficiaries are given in the following table. Sr.No. Category of Farmer Beneficiary's Contribution
Small farmers
5%
Medium farmers
10%
Large farmers
15%
7.4 Security Security will be as per NABARD / RBI guidelines issued from time to time. 7.5 Repayment Period of Loan Repayment period depends upon the gross surplus generated. The loans will be repaid in suitable half yearly / annual instalments usually within a period of about 67 years with a grace period 30 months. Scheme for financing heifer rearing along with a dairy unit ASSUMPTIONS : The beneficiary will be financed for 1+1 Dairy Unit (2 animals at 6 months interval). The calf of the first animal is assumed to be female and feed for its growth inclusive of pregnency is provided (4-28 months). If the record animal's calf is also female, the unit cost can be suitably enhanced to finance its growth also. The calf is sold as first lactating animal during the third year. i.e. it will be impregnanted around 18-20months of age. Provision of dry fodder to the calf will be additional requirement to be net by the farmer.
A.FEEDING SCHEDULE FOR CALF : Sr. No. Age of the calf in months Kgs of conc. feed/day (Feed consumption) Total Feed consumed Progressive Total
1.
4-6 (3)
1.00
90
90
2.
7-8 (2)
1.25
75
165
3.
9-12 (4)
1.75
210
375
4.
13-16 (4)
2.00
240
615
5.
17-28 (12)
2.25
810
1425
6.
Pregnancy Ration from 5th month of Pregnancy i.e. from 24th month to 28th month
1.50
225
1650
B.FEED REQUIREMENT (YEAR-WISE CALF REARING) During I year of the Project During II year of the Project During III year of the Project Total 1650 Kgs Feeding concentrates to the calf will start during 4th month of the project. C. CAPITAL COST : 375 Kgs * 825 Kgs 450 Kgs
(i)
1+1 Dairy
a.
Rs.24000.00
b.
Rs.1000.00
(ii)
Calf Rearing
c.
Cost of feeding from 4th to 28th month of age (1650 Kgs @ Rs.5.00/Kg)
Rs.7750.00
d.
Rs.250.00
e.
Rs.250.00 Rs.33250.00
D.
Sr. No.
PARTICULARS
YEARS
II
III
a.
1+1 Dairy
i.
Cost of 2 animals
24000.00
--
--
ii.
1000.00
--
--
b.
Calf Rearing
i.
Cost of feed
1760.00
3880.00
2110.00
ii.
Cost of insurance
250.00
--
--
iii.
75.00
75.00
100.00
27085.00
3955.00
2210
Margin @15%
5000
Bank Loan
28250
1. 2. 3. 4. 5. 6. 7. Sr. No.
Average milk yield - 6 lit/lact.day. Selling price of milk - Rs.9.50/lit Sale of manure Value of animal Insurance Vet. aid - Rs.300/ani/year - Rs.1000 at end of 5th lact.
Qty.
Price
Qty.
Price
1.
Concentrate @ Rs.6/Kg.
Kg
Rs
Kg
Rs
a.
1.0
6.00
1.0
6.00
b.
Production
2.0
12.00
--
--
c.
Pregnancy
--
--
0.5
3.00
2.
5.0
2.50
5.0
2.50
3.
15.0
3.75
15.0
3.75
27.25
15.25
F.Calculation of IRR
Sr. No.
Particulars
Years I II III IV V
1.
Cost
27085
3955
2210
10770
11420
2.
Benefit
10465
11220
23220
10770
1142
3.
Net Benefit
(16520)
7265
21010
0.197
0.131
4.
DF@50%
0.666
0.440
0.296
2122
1496
5.
PN
(11069)
3197
6219
--
--
NPW = +468.33
IRR = is more than 50% G. Repayment Schedule Year Total o/s at begining Loan disbursed Total loan Net income Repayment Net Surplus
Net @10%
Principle
--
23000
23000
10465
2300
4000
4186
II
19000
3360
22360
11220
2236
4500
4484
III
17860
1890
19750
23220
1975
10000
11245
IV
9750
--
9750
10770
975
4500
5295
5250
--
5250
11420
525
5250
5645
go to top
NABARD 2007
Privacy Policy | Disclaimer | Feedback | Contact us | Sitemap Site designed & developed by : Lintas Personal (SRS), 2007 Site maintained by : Sify Technologies Limited.