Professional Documents
Culture Documents
Applicable Machines: , IP-602M 3. Remove the interface cable connector connected to the hard disk by grasping the pull-tab and pulling it out.
I. Handling lnstructions
1. Precautions against static electricity Keep the expanded memory unit in an antistatic bag while transporting it or storing it. When working in places where static electricity tends to accumulate, such as on a carpet, discharge electricity from your body by touching any metallic portion before handling the expanded memory unit. 2. Do not touch the contacts on the expanded memory unit with your hands, as that may result in poor conductivity. 3. Do not physically damage the expanded memory unit by dropping it, bending it, etc.
Interface cable
Printer controller
Pull-tab
Hard disk
III.Installation Procedure
[1050/1050P]
1. Turn the Main and Sub switches OFF, and unplug the power cord from the outlet. 2. Remove the back cover of the main body (9 screws). 5. Remove the control board cover of the printer controller (17 screws).
Back cover
E-1
15BV97010
6. Install the expanded memory unit. Note: When installing the expanded memory unit be sure that the cutout properly matches the slot on the motherboard. To install, open both slot clamps, and insert the expanded memory unit while holding it at a 90degree angle to the motherboard, until the clamps click shut.
[IP-602M]
1. Remove the IP-602M from the main body, if it is installed. (1) Before beginning the setup procedure, turn off the power supply to the IP-602M and the main unit, then unplug the power cord. (2) Remove the IP-602M from the main body.
7. Reinstall the control board cover of the printer controller (17 screws). 8. Reinstall the printer controller to the main body by aligning it with the pins and securing it with 6 screws. Make sure the back connector clicks in when it is connected.
2. Remove the outside cover by removing the two screws at the rear of the printer controller.
Pins
3. Remove the reinforcement board (2 screws). 9. Connect the interface cable to the hard disk. 10. Reinstall the back cover (9 screws).
Reinforcement board
Screws
E-2
4. Install the expanded memory unit. Note: When installing the expanded memory unit be sure that the cutout properly matches the slot on the motherboard. To install, open both slot clamps, and insert the expanded memory unit while holding it at a 90degree angle to the motherboard, until the clamps click shut.
5. Reinstall the Reinforcement board (2 screws). Note: Press the reinforcement board in the direction of the arrow, then fix it.
Reinforcement board
Screws
6. Reinstall the outside cover (2 screws). Note: Reinstall the outside cover by pressing it down so that it slides into position.
E-3