Professional Documents
Culture Documents
ISO 525:1999
AS 4523—2005
Australian Standard™
This is a free 7 page sample. Access the full version at http://infostore.saiglobal.com.
Australian Standard™
This is a free 7 page sample. Access the full version at http://infostore.saiglobal.com.
COPYRIGHT
© Standards Australia
All rights are reserved. No part of this work may be reproduced or copied in any form or by
any means, electronic or mechanical, including photocopying, without the written
permission of the publisher.
Published by Standards Australia, GPO Box 5420, Sydney, NSW 2001, Australia
ISBN 0 7337 6492 4
ii
PREFACE
This Standard was prepared by the Standards Australia Committee ME-033, Abrasives, to supersede,
AS/NZS 4523:1998, Bonded abrasive products—General—Designation, marking, range of outside
diameters and tolerances.
This Standard is identical with and has been reproduced from ISO 525:1999, Bonded abrasive
products—General requirements.
The objective of this Standard is to provide manufacturers and users of bonded abrasive products with
general requirements for these products.
The objective of this revision is to adopt the current edition of ISO 525.
As this Standard is reproduced from an international Standard, the following applies:
(a) Its number appears on the cover and title page while the International Standard number appears
This is a free 7 page sample. Access the full version at http://infostore.saiglobal.com.
CONTENTS
Contents
1 Scope ....................................................................................................................................................................... 1
3 Symbols ................................................................................................................................................................... 3
5 Requirements ........................................................................................................................................................ 14
This is a free 7 page sample. Access the full version at http://infostore.saiglobal.com.
6 Designation ........................................................................................................................................................... 18
7 Marking .................................................................................................................................................................. 19
© ISO 1999
All rights reserved. Unless otherwise specified, no part of this publication may be reproduced or utilized in any form or by any means, electronic
or mechanical, including photocopying and microfilm, without permission in writing from the publisher.
International Organization for Standardization
Case postale 56 • CH-1211 Genève 20 • Switzerland
Internet iso@iso.ch
Printed in Switzerland
ii
This is a free 7 page sample. Access the full version at http://infostore.saiglobal.com.
iv
NOTES
1
1
AUSTRALIAN STANDARD
Bonded abrasive products — General requirements
Bonded abrasive products—General requirements
1 Scope
This International Standard covers bonded abrasive products in general (grinding wheels, segments, sticks and
stones) excluding abrasive products with diamond or cubic boron nitride.
It gives:
the designation;
This is a free 7 page sample. Access the full version at http://infostore.saiglobal.com.
specifications;
the marking.
This International Standard is general and is complemented by ISO 603-1 to ISO 603-16, ISO 6103 and ISO 13942.
2 Normative references
The following normative documents contain provisions which, through reference in this text, constitute provisions of
this International Standard. For dated references, subsequent amendments to, or revisions of, any of these
publications do not apply. However, parties to agreements based on this International Standard are encouraged to
investigate the possibility of applying the most recent editions of the normative documents indicated below. For
undated references, the latest edition of the normative document referred to applies. Members of ISO and IEC
maintain registers of currently valid International Standards.
ISO 603-1, Bonded abrasive products — Dimensions — Part 1: Grinding wheels for external cylindrical grinding
between centres.
ISO 603-2, Bonded abrasive products — Dimensions — Part 2: Grinding wheels for centreless external cylindrical
grinding.
ISO 603-3, Bonded abrasive products — Dimensions — Part 3: Grinding wheels for internal cylindrical grinding.