You are on page 1of 4

UPPCL Technical Interview Question Paper 2011 Placement Model Quest...

http://www.jbigdeal.com/2011/03/uppcl-technical-interview-question-pa...

Home

Papers

TET 2011-2012

Study Materials Coaching Center

Govt. Jobs

What's New?

Terms of use

UPPCL Technical Interview Question Paper 2011 Placement Model Question Paper
Free download Technician (Trainee) Assistant Engineer (Trainee) Jr. Engineer (Trainee) Electrical Jr. Engineer (Trainee) Electronic/ Tele Communication Engineer (Trainee) Civil UPPCL 53. When a material is subjected to continuous cycles which limit is being verified? (Endurance limit) 54. where is stress concentration maximum? (notches, stress reducing throughcuts) 55. Power transmitted through a belt drive_? P(T2-T1) 56. According to Eulers theory crippling or buckling load is (Wcr = C?2EI/l2) 57. During sensible heating, specific humidity_? (remains constant) 58. COP of a refrigerator is _? (greater than 1 ) 59. The maximum temperature in a refrigeration cycle is_? (less than/greater than/equal to critical temperature) 60. The pressure at the throat of the nozzle_? (maximum,min) 61. for a statically determinate set of forces for equilibrium_? (? f(X),f(Y),f(Z)=0,?M=0) 62. For a statically determinate set of forces(there r as many equations as the no. of unknowns) 63. 1-2-3 analysis is used for_? (1.break even analysis, ??) 64. A problem on mean time of service something like a salesman has a rating of 120. considering 10% allowance time calculate the time required to serve 120??? 65. A problem n determining time in a queue?? 66. Energy equation for a laminar flow is _? (Uniform and steady ,non uniform and unsteady) 67. Undercuts in welding occurs due to_? (low welding current,high welding current) 68. Work holding equipment in shearing?? 69. At the centre of a nozzle _? (Mach no=1;=1) 1. What is causal system? 3. 20w, 40W, & 200w lamps are connected to three phases if neutral wire breaks then which lamp will fuse first? 1) 20 2)40 3)200 three lamps will fuse together. 4. Synchronous machine can be operated at both lagging and leading power factor 5 What does synchronous speed mean? 6. Frequency of emf generated per rotation of rotor is equal to. 7. DC machine having wave winding is wounded as lap winding what will be the effect on emf generated 8 Which is remain unchanged in transformer action? 9. In transformer windings are connected.? 10. In general how transformer is rated? 11. What is given on the name plate of motor? 1) KW 2) KVA 3) output shaft power

1 of 4

10/28/2011 11:17 AM

UPPCL Technical Interview Question Paper 2011 Placement Model Quest...

http://www.jbigdeal.com/2011/03/uppcl-technical-interview-question-pa...

12. Short circuit test of transformer gives what? 13. Transformer core are laminated for what purpose? 14. What is supply voltage for heavy industry .1) 33KV 2) 11KV 3) 132 KV 4) 66KV 15. Basic structure SCR as a two transistor i.e. how they are connected? 16. What is Triac? 17. System admittance is (G+jB) what is reactive power absorbed if the voltage is V KV? (1) V (square)*B (2) V (square)*g . 18. In series R-L circuit what is phase difference between the voltage drop across R and L? 19. Power factor is cosine (delta ) delta is the angle between 1) phase voltage phase current 2) Line voltage lone current 3) phase voltage line current 4) line voltage phase current. 20. Laplace of exp (-at)? 21. For series R-L-C circuit the load will be capacitive if the frequency is 1) greater than the resonant frequency 2) less than the resonant frequency 3). 22. In Wiens bridge which circuit elements determine the frequency range? 23. What is the output if two booster having duty cycle K and (K-1) are connected in series? 24. If a DC shunt motor is loaded from unloaded condition what will be effect of on terminal voltage? 25. A second wire system having one pole one right half of the s-plane. When the system will be stable? 26. A system having repetitive pole what will be effect on the gain at the cross over frequency? 27. Hollow conductor is used to reduce corona loss how does it reduce the loss? 28. In DC machine how voltage is related to flux? 29. Nature of current and voltage in the armature and at the terminal in DC machine. 30. Motor acts on the principle of ..rule 31. Which instrument measure both ac and dc? 32. How the rotation of induction motor is reversed? 33. If 3-phaseof a 3- phase balance load are reversed what will be the effect on the line current? 34. If the rating of VAR absorber is 50MVAR at 400KV. What will the VAR absorbed by the absorber at 300KV? 35. In regenerative breaking of DC series motor what is done? 36. Definitions of Fourier transform? 37. Laplace of f(t) is F(S) what is Laplace of f(t+T) . 38. Z-transform of sampled function x(n) for n>0. 39. Laplace transform of impulse function. 40. Z-transform of unity. 41. How many slip rings are there in 3phase synchronous motor? 42. How the speed of synchronous motor is controlled? 43. Speed control of induction motor? 44. When power supply is supplied to heater coil it glows while simple wire does not glow. Why? 45. A synchronous generator having inertia constant 4 and having rating of 100MVA. What will be energy stored by the machine? 46. A transformer having ratio 20:1. The secondary load is 0.6 ohm and the voltage across it is 6 V what will be the primary current? 47. A RC circuit having r=0.8ohm, c=2.5micofarad what will be the time constant? 48. Find load impedance if c=0.1 micro farad?

2 of 4

10/28/2011 11:17 AM

UPPCL Technical Interview Question Paper 2011 Placement Model Quest...

http://www.jbigdeal.com/2011/03/uppcl-technical-interview-question-pa...

49. Two capacitors connected in series the equivalent capacitance is 0.03uf and when connected in parallel the equivalent capacitance is 0.16uf find out the ratio of the two capacitance? 50. An L-c circuit having frequency 1/sqrt (LC) what will the equivalent impedance? 51. An inverting op-am having input with resistance in series and a capacitance in feedback operates as a.? 52. A current having fundamental and third harmonics what will be the rms value of the current? 53. Peak to peak value of voltage if rms voltage is 100V. 54. Rms voltage. 56. What is the average current of a single phase full wave rectifier firing at angle alpha? 57. What is the function of freewheeling diode? 58. When SCR stops conduction? (holding current) 59. For measuring current why shunt resistance is used? 60. For economic operation of plant what is the condition?(taking into account the penalty factor) 61. Incremental fuel cost of two plants is given and a load is given. Find out the load sharing for economic operation of the plant? 62. A two port network is represented by ABCD parameters. What will be condition for the two port network to be symmetrical? 63. Size of the conductor is determined by . 64. Which Surface is suitable for grounding?

Similar Pages..
UPPCL Technician|Trainee Question paper UPPCL Assistant Engineer (Trainee) Question Paper UPPCL Jr. Engineer (Trainee) Electrical Question Paper UPPCL Jr. Engineer (Trainee) Tele Communication Engineer Question Paper

Other Pages..

UPPCL Electrical Jr. Engineer (Trainee) Question Paper 2011 Model Papers Free download pdf (Uttar Pradesh Power Corporation Limited UPPCL Question Paper Last 10 Years Papers with solution, Last Year UPPCL Question Papers, Previous year UPPCL ... NTPC EE Electrical Engineering Question Paper 2009 NTPC Placement Paper NTPC Question Paper with Answer key free Download Free NTPC Sample question papers NTPC Model question papers NTPC mock test papers Electrical Engineering NTPC NTPC ... Power Grid Technical Question Paper Answer 2011 Placement Paper of PGCIL PGCIL Power Grid Technical Question Paper 2011 Placement paper of Power Grid Technical1. resistance of ideal transformer windingans. zero2. hysteresis loss in transformer depends on ... UPPCL Technician|Trainee Question Paper 2011 Model Paper Free download pdf (Uttar Pradesh Power Corporation Limited UPPCL Question Paper Last 10 Years Papers with solution, Last Year UPPCL Question Papers,what is the advantages ... EIL Management Trainee Electrical Question Paper Sample model paper EIL Management Trainee Electrical Question Paper Sample model paper1. Mho relay is usually employed for the protection ofa) Short lines onlyb) Medium lines onlyc) Long ... Model Paper with answer Q1 Which of the following has high electrical resistivity(a) Copper (b) Gold (c) Carbon (d) SilverQ2 The resistance of 200 m. long circular copper wire ... Mahatransco Jr. Engineer Question Paper Sample Model Jr. Engineer Trans Trainee Paper Free download pdf Maharashtra State Electricity Transmission Co. Ltd. Mahatransco Last 10 Years Papers with solution, Last Year Mahatransco Question Papers, Previous year Mahatransco Question ... BSNL TTA Electrical Question Papers with answers 2011

3 of 4

10/28/2011 11:17 AM

UPPCL Technical Interview Question Paper 2011 Placement Model Quest...

http://www.jbigdeal.com/2011/03/uppcl-technical-interview-question-pa...

Free download pdf Telecom Technical Assistants BSNL TTA ElectricalBSNL TTA Electrical Question Papers with answers 2011 pdf Previous Year Papers of BSNL TTA Electrical Solved1. ... NHPC Question Paper Electrical Placement Paper Trainee Engineer Free download pdf Uttar Pradesh Combined Pre Medical Test NHPC Last 10 Years Papers with solution, Last Year NHPC Question Papers, Previous year NHPC Question ... DMRC Junior Engineer Electrical Question Papers 2012 Sample Paper Free pdf download pdf DMRC Junior Engineer Electrical Delhi Metro Rail Corporation Paper junior engg Electronics Question Papers station controller & JE (Mech). DMRC Junior ... Question Bank on Electrical, Electronics Instrumentation Question Bank on Electrical, Electronics Instrumentation1. In order for a 30 volt, 90 watt lamp to work properly in a 120 volt supply the required ... KPCL Electrical Question Paper for Assistant and Junior Engineer Free download pdf karnataka power KPCL Assistant Engineer Question Paper Previous Year Old Papers karnataka power 2012 Last 10 Years Papers with solution, Last Year ... Question Bank Answer on power Q.A wave will not experience any reflection when impedance of line is equal toa surge impedanceb load impedancec >surge impedancedAns: surge impedanceQ.if the length of ... APGenco Test Question Paper Answer APGenco Test Question Paper AnswerClick Here for More question papersQ1 Which of the following has high electrical resistivity(a) Copper (b) Gold (c) Carbon (d) SilverQ2 ... OHPC GET Electrical Question Paper Answer Sample Model Paper Free download pdf OHPC GET Electrical Question Paper Answer Sample Model Paper Orissa Hydro Power Corporation Limited OHPC Placement Paper Last 10 Years Papers with ...
| Trackback | Permalink

4 of 4

10/28/2011 11:17 AM

You might also like