Professional Documents
Culture Documents
: : :
Geometry Construction
Creating and designing an automobile using ABACUS and WORKBENCH (ANSYS) software. 1) Automobile without using a spoiler.
Result
1) Automobile without using spoiler
c) Velocity vector
d) Flow separation
e) Pathlines
d) Pathlines
d) Pathlines
Discussion
Based on the result, the ANSYS software has generate the value of the three automobile. From that we can calculate by using the formula : = 1 2 2
Given data: = 1.225/3 , = 30/, = 2.22 0.69 1.32 0.78 836.79N 1600.83N 945.94
When creating the model, the result of the is higher than the usual specification. This problem occurs because of the design is in 2D, but if the design is in 3D then the result of will be lower.
Conclusion
From the result, we can see that with an attaching the spoiler to the automobile it will increase the of the vehicle but this will effect also on increasing the down force. When designing a vehicle or a car, if it is more focus on saving fuel consumption than it will need a lower but if designing the car for circuit purpose than it will need a higher .