You are on page 1of 1

www.installdr.

com
Mitsubishi Radio Wire Harnesses
Up To 1998-1999 Mitsubishi-Chrysler Corp Typical New Radio
Pin What It Is In Dash Wire Color Equivalent Wire Color
A Right Front Speaker (+) (2) White w/ Red Stripe Gray
B Right Rear Speaker (+) Yellow w/ Red Stripe Purple
C Do Not Use
A B F G J M D Left Front Speaker (+) (2) White w/ Blue Stripe White
C D E H I K L N E Left Rear Speaker (+) Yellow w/ Blue Stripe Green
F Light Dimmer Wire
G Headlight Illuminiation
H +12 Volt Battery Wire Red w/ Black Stripe Yellow
I +12 Volt Ignition Wire Blue Red
AS VIEWED FROM MATING END OF CONNECTOR
J Left Rear Speaker (-) Gray w/ Blue Stripe Green w/ Black Stripe
K Right Rear Speaker (-) Gray w/ Red Stripe Purple w/ Black Stripe
L Power Antenna Turn On Blue
M Left Front Speaker (-) (2) Black w/ Blue Stripe White w/ Black Stripe
N Right Front Speaker (-) (2) Black w/ Black Stripe Gray w/ Black Stripe
NOTE: this vehicle does not have a (-) Ground Wire attached to either connector. The
radio grounds when the metal brackets attached to the radio screw into the metal dash
or the ground wire from the new radio is screwed into metal of the vehicles dash.

1998-1999 And Newer Typical Mitsubishi Typical New Radio


Pin What It Is In Dash Wire Color Equivalent Wire Color
A Right Rear Speaker (+) Aqua Purple
B Left Rear Speaker (+) Yellow w/ Blue Stripe Green
C Power Antenna Turn On Blue
A B C H I J D Right Rear Speaker (-) Yellow w/ Green Stripe Purple w/ Black Stripe
E Left Rear Speaker (-) Yellow w/ Red Stripe Green w/ Black Stripe
D E F G K L M N
F Do Not Use
G +12 Volt Ignition Wire Blue Red
H Do Not Use
I Left Front Speaker (+) Red w/ White Stripe White
AS VIEWED FROM MATING END OF CONNECTOR
J Right Front Speaker (+) Red Gray
K +12 Volt Battery Wire Red w/ Black Stripe Yellow
L Do Not Use
M Left Front Speaker (-) Red w/ Blue Stripe White w/ Black Stripe
N Right Front Speaker (-) Blue Gray w/ Black Stripe

Note: using an optional snap on wire harness adapter will simplify the wiring. Most snap on wire harness adapters have already converted and color coded
the wires from the auto makers in dash wire harness to match typical aftermarket radio wire colors.

** The wire colors listed in the chart above are typical for these vehicles during these years but may not be the exact colors for this vehicle. This is another
reason to use a snap on wire harness adapter. **

Publication, Duplication, or Retransmission Of This Document Not Expressly Authorized In Writing By The Install Doctor Is Prohibited. Protected By U.S. Copyright Laws. © 1997,1998,1999,2000.

All Information, Including Photos And Illustrations, In These Pages Is Believed To Be Correct And Reliable. The Information Contained In These Pages Is Given As General Information For The Installation Of Audio, Video, Security, Communications,
And Other Accessory Products Into Mobile And/Or Vehicle Applications. The Install Doctor, Any Subsidiaries Or Divisions Thereof, Or Any Member Of These Companies Shall Not Be Held Liable For Any Damages And/Or Injuries Resulting From
The Use Of Information Contained In These Pages. All Information Contained In These Pages Should Be Checked And Verified With Appropriate Test Equipment To Assure The Safety And Proper Operation Of Equipment Installed And The Vehicle
Itself. Careful Attention Should Be Given To All Electronic/Electric Circuits. High Voltages And Currents Can Cause Bodily Injury, Skin Damage, And Even Death. Installs Are Taken At The Risk Of Each Installer, And/Or Individual.

You might also like