You are on page 1of 421

STANDARD SPECIFICATIONS FOR ROAD AND BRIDGE WORKS

CONTENTS
Section Page
SERIES 1000: GENERAL

1100 Definitions and terms 1100-1


1200 General requirements and provisions 1200-1
1300 Contractor’s establishment on site and general obligations 1300-1
1400 Housing, offices and laboratories far the engineer’s site personnel 1400-1
1500 Accommodation of traffic 1500-1
1600 Overhaul 1600-1
1700 Clearing and grubbing 1700.1

SERIES 2000: DRAINAGE

2100 Drains 2100-1


2200 Prefabricated culverts 2200-1
2300 Concrete kerblng, concrete channelling, chutes and downpipes, and
concrete linings for open drains 2300-1
2400 Asphalt and concrete berms 2400-1

SERIES 3000: EARTHWORKS AND PAVEMENT LAYERS OF GRAVEL OR


CRUSHED STONE

3100 Borrow materials 3100-1


3200 Selection, stockpiling and breaking-down the material from borrow pits and cuttings,
and existing pavement layers, and placing and compacting the gravel layers 3200-1
3300 Mass earthworks 3300-1
3400 Pavement layers of gravel material 3400-1
3500 Stabilization 3500-1
3600 Crushed-stone base 3800-1
3700 Plant-mixed paver-laid pavement layers 3700-1
3800 Breaking up existing pavement layers 3800-1
3900 Patching and repairing edge breaks 3900-1

SERIES 4000: ASPHALT PAVEMENTS AND SEALS

4100 Prime coat 4100-1


4200 Asphalt base and surfacing 4200-1
4300 Seals: Materials and general requirements 4300-1
4400 Single seals 4400-I
4500 Double seals 4500.1
4600 Bituminous single seal with slurry (Cape seal) 4600-1
4700 Surfacing of bridge decks 4700-1
4800 Treatment of an existing surface exhibiting certain defects 4900-1
4900 Sand seals 4900-1

SERIES 5000 ANCILLARY ROADWORKS

5100 Pitching, stonework and protection against erosion 5100-1


5200 Gabions 5200-1
5300 Guide blocks 5300-1
5400 Guardrails 5400-1
5500 Fencing 5500-1
5800 Road signs 5600-1
5700 Road markings 5700.1
5800 Landscaping and planting plants 5800-1
5900 Finishing the road arid road reserve and treating old roads 5900-1
Section Page
SERIES 6000: STRUCTURES

6100 Foundations for structures 6100-1


6200 Falsework, formwork and concrete finish 6200-1
6300 Steel reinforcement for structures 6300-1
6400 Concrete for structures 6400-1
6500 Prestressing 6500-1
6600 No-fines concrete, Joints, bearings, bolt groups for electrification, and parapets
and drainage for structures 6600-1
6700 Structural steelwork 6700-1
6800 Construction tolerances for structures 6800-1

SERIES 7000: SUNDRY STRUCTURES

7100 Concrete pavements 7100-1


7200 Reinforced earth 7200-1
7300 Concrete block paving for roads 7300-1
7400 Patented earth retaining systems 7400-1
7500 Ground anchors

SERIES 8000: SUNDRIES

8100 Testing material and workmanship 8100-1


8200 Quality control (Scheme I) 8200-1
8300 Quality control (Scheme 2) 8300-1
8400 Painting 8400-1

You might also like