Professional Documents
Culture Documents
Doc. Id No.
BMI-WI-5711-11
DATE
00.00.0000
REVISION
0
PAGE
1 of 5
WORK INSTRUCTION
WI-5711-11 API6D Valve Marking
Revision No.: 0
Effective Date:
Prepared By:
Reviewed By:
Approved by:
Signature
Name
Designation
Date
Page
Doc. Id No.
BMI-WI-5711-11
DATE
00.00.0000
REVISION
0
PAGE
1 of 5
Purpose
(To establish a marking procedure for API 6D valves.) This procedures cover to the
quality requirements on marking of API6D valves.
2. Scope
This applies to all PT BMI manufactured API6D valves products both body and
nameplate.
3
Responsibility
a) Marking Operator
b) Production Manager
c) QC Inspector
d) QA/QC Manager
Approved the markings base on the following standard (ASME 16.34 and
API6D)
Page
Doc. Id No.
BMI-WI-5711-11
DATE
00.00.0000
REVISION
0
PAGE
1 of 5
Marking Details:
4.1 Valves shall be mark in accordance with the requirements of table 7 of API6D 24th
Edition:
No.
1a
1b
2
3
Marking
Manufacturers name
Trademark or mark (optional)
Pressure Class
Pressure temperature rating:
Location
On body and/or nameplate
On body and/or nameplate
On both body and/nameplate
On nameplate
On nameplate
On both body/closure end connection and
material grade
Bonnet/cover materials designation
4
5
On nameplate
of body
Nominal Valve size
On valve flange OD
On Body weld ends
11
12
applicable
Flow direction (for check valves only)
Seat sealing direction (valves with
On body
On body
13
On nameplate
Doc. Id No.
BMI-WI-5711-11
DATE
00.00.0000
REVISION
0
PAGE
1 of 5
DBB,DIB-1, or DIB-2
14
respective(where applicable)
QSL level: QSL-1,QSL-2,QSL-3 or
On nameplate
15
16
17
18
number)
Product specification number(if
On nameplate
applicable)
a. When body is manufactured from more than one type of material, both the body and endconnection material shall be identified.
b. MSS SP-25 gives guidance on marking
c. Where the grade and class does not uniquely identify the material specification, the material
specification, grade and class shall be marked. Example: A516-70
4.2
Page
4.3
Doc. Id No.
BMI-WI-5711-11
DATE
00.00.0000
REVISION
0
PAGE
1 of 5
Note:
Nameplate minimum letter size is 0.125in (3mm) on valves sizes NPS 2 (DN 50) and
larger. For all valves NPS 1.5 (DN 38) and smaller is 1.5mm.
Page
Doc. Id No.
BMI-WI-5711-11
DATE
00.00.0000
REVISION
0
PAGE
1 of 5
Procedure
5.1
Make sure that the marking machine and air compressor are both in good
running conditions.
5.2
Set up the marking equipment and input the marking details to the program
for both body and nameplate marks.
5.3
5.4
6. Marking Inspection
6.1
6.2
(1)Simulation of CNC program for both body and nameplate shall be done
prior to final markings.
6.3
Page