You are on page 1of 6

Kwant Controls B.V.

Postal address: Internet:


Tel. +31 (0)515 413745 P.O.Box 23 email: kwant@kwantcontrols.nl
Fax +31 (0)515 422478 SNEEK HOLLAND website: www.kwantcontrols.com











Bargraph Indicators
LBM-X Series

























Kwant Controls B.V. Postal address: Internet:
Tel. +31 (0)515 413745 P.O.Box 23 email: kwant@kwantcontrols.nl
Fax +31 (0)515 422478 SNEEK HOLLAND website: www.kwantcontrols.com

BARGRAPH INDICATORS

The Kwant Controls bargraph indicators of the LBM-series come in a number of basic types:

LBM-1: Zero position at the end of the scale, input signal 4-20mA or 0-10VDC.

LBM-4: Zero position in the middle of the scale, input signal 10/0/+10VDC.

LBM-5: Zero position in the middle of the scale, input signals 4-20mA or 0-10VDC.


A number of 41 light emitting diodes (LEDs) in either green, red or
yellow is used to display the input signal, therefore the display
resolution is 2,5%. All types can be dimmed by means of an external
low cost potentiometer, and have dial illumination in matching colors.
The housing is made of black anodized aluminum, while the
electronic circuitry has been sealed with a hardening compound to
ensure trouble free operation. The reading can be adjusted by
means of two trimmer potentiometers located at the back of the unit.
The LBM-4 and 5 are available in Horizontal or Vertical orientation.


Please check the following table to select the LBM matching your
application:


Type: Part no: Input signal: Colors: Loc: Dimensions:
LBM-1 15017000 4-20mA R-R Fwd,Aft 4A0100597
LBM-4HF 15017001 -10/0/+10V R-Y-G Fwd 4A0103497
LBM-4VF 15017003 -10/0/+10V R-Y-Y Fwd 4A0103496
LBM-5HF 15017011 4-20mA R-Y-G Fwd 4A0103497
LBM-5VF 15017021 4-20mA R-Y-Y Fwd 4A0103496
LBM-4HA 15017002 -10/0/+10V G-Y-R Aft. 4A0103497
LBM-4VA 15017004 -10/0/+10V Y-Y-R Aft. 4A0103496
LBM-5HA 15017013 4-20mA G-Y-R Aft. 4A0103497
LBM-5VA 15017023 4-20mA Y-Y-R Aft. 4A0103496


NOTE:

Precautions must be taken when used outdoors, the LBMs should not be exposed to direct
sunlight because of the reduced visibility of the LED indication. A sunlight readable version is
available, however with ultra bright RED leds only.


All LBM indicators have been CE-approved and fulfill the Marine Equipment Directive.

You might also like