Professional Documents
Culture Documents
Antenna 2
General specications:
Frequency range 17102200 MHz Azimuth direction Beam A (-30), Beam B (+30) Impedance 50 ohms VSWR < 1.5:1 Intermodulation (2x20w) IM3:< -150 dBc Polarization +45, -45, +45, -45 Front-to-back ratio >30 dB (co-polar) >25 dB (total power) Maximum input power 200 watts per input (at 50C) Connector 4 x 7-16 DIN female Isolation >30 dB Horizontal pattern Sidelobe suppression for >18 dB sidelobes beside main beam Vertical pattern Sidelobe suppression for >18 dB rst sidelobe above main beam Electrical downtilt 010 (continuously adjustable) Weight 41.9 lb (19 kg) 46.3 lb (21 kg) clamps included Dimensions 51.7 x 15 x 5.9 inches (1314 x 380 x 150 mm) Wind load at 93 mph (150kph) Front/Side/Rear 160 lbf / 45 lbf / 185 lbf (710 N) / (200 N) / (820 N) Mounting category M (Medium) Wind survival rating* 120 mph (200 kph) Shipping dimensions 66.8 x 15.8 x 6.8 inches (1696 x 402 x 172 mm) Mounting Fixed mounts for 2 to 4.6 inch (50 to 115 mm). OD masts are included. See reverse for order information.
10
30
30
33 0 0
20
60
30
270
90
24
12
15
21
180
10
30
30
33 0 0
20
60
30
270
90
24
12
15
21
180
Vertical pattern 45-polarization Beam A (-30), Beam B (+30) 010 electrical downtilt
Specications:
Gain Horizontal beamwidth (offset beams 30) Vertical beamwidth Cross polar ratio Main direction -30; +30 Sector -60; 0; 0; +60
* Mechanical design is based on environmental conditions as stipulated in TIA-222-G-2 (December 2009) and/or ETS 300 019-1-4 which include the static mechanical load imposed on an antenna by wind at maximum velocity. See the Engineering Section of the catalog for further details.
11308-C 936.4001/c Kathrein Inc., Scala Division Post Ofce Box 4580 Medford, OR 97501 (USA) Phone: (541) 779-6500 Email: communications@kathrein.com Internet: www.kathrein-scala.com
800 10606V01
45 Quad Port Split Beam Panel Antenna
Order Information:
Model Description 800 10606V01 45 Dual-beam antenna
All specications are subject to change without notice. The latest specications are available at www.kathrein-scala.com.
Kathrein Inc., Scala Division Post Ofce Box 4580 Medford, OR 97501 (USA) Phone: (541) 779-6500 Email: communications@kathrein.com Internet: www.kathrein-scala.com Fax: (541) 779-3991
800 10606V01
45 Quad Port Split Beam Panel Antenna 6 Sector Deployment
0 330
3
Antenna I Beam A
30
Antenna I Beam B
300
60
10
20
270
90
Antenna II Beam B
240 120
Antenna II Beam A
210 180
150
Antenna III
47 Dou 0 t m m
Antenna II
Bottom view
Specications:
742 034 Sector Bracket Angle between antennas 120 Suitable for mast diameter* 5.5 inches (139.7 mm) OD. Number of pieces 2 x 3 sector clamp 2 x mounting support clamp Materials 3 sector clamp Hot-dip galvanized steel Mounting support clamp Aluminum Screws Hot-dip galvanized steel Nuts Stainless steel Outer diameter (Dout) of the 18.5 inches (470 mm) 3 Dual-beam Panel Arrangement * Customer assumes all responsibility to ensure that the mounting pipe is adequate to support the intended load. For use with steel pipe only (not aluminum) with a minimum 0.25 inch (6 mm) wall thickness. Weight Wind load Front/Side/Rear Wind survival rating* 3 Panel Arrangement 132.3 lb (60 kg) at 93 mph (150kph) 214 lbf / 214 lbf / 214 lbf (950 N) / (950 N) / (950 N) 120 mph (200 kph)
60
A
C D Torque 25 Nm
Dimensions:
inches mm
742 034 sector bracket with 800 10606 antennas A B C D E F G Dout 5.5 3.9 9.3 9 2.5 2 1.8 18.5 139.7 100 236 228 64 50 45 470
All specications are subject to change without notice. The latest specications are available at www.kathrein-scala.com.
Kathrein Inc., Scala Division Post Ofce Box 4580 Medford, OR 97501 (USA) Phone: (541) 779-6500 Email: communications@kathrein.com Internet: www.kathrein-scala.com Fax: (541) 779-3991
Specications: