Rofit
7. Reverse remaval procedure,
‘@. Tighten Tore strews securing seat to 29 Nm (21
oF.
9. Tighian bolls securing seat slides to 22 Nim (16
wt fy.
10. Tighten Torx sevew securing seat bell lo 32 Nm
(24 db fy)
“To remave andi replace the interior rear.view minor ina 1997
Discovery.
Remove:
= Remove both sun visors and the mounling clipe (3 machine
serevie atthe pivet end one sheet metal errew af tne ep;
tive the cle & tug and il come out ofits sacket)
= Remove the plastic averhead bincontrols facie - about 5-5
sheet matslescrewe per side, then disconect wire plugs
= Ramove ene ef te serewe that hold the sunroof eariel tox
In place, neeause tne mutiplug for the rear-vlee miro ty
sezewed down under one side of the contr bow.
= Unplug the rearview malig and get ready to knock the
rior eff ts bracket. Main thing to realize is that i's on
spring clip and mede to come Inoge if samenne's heed
Wwhaeks iL So, emavalis @ Ni dowrwised blow to Bap I of
TTused & plastic black placed against he top af the mirar base
ssbaul where the “2b in the Egute {to the right). ive the block
fe shert, miki whck wien @ hammer of ether weight - your hans
might even be enough. ALSO, make une youre holding tne
iro, $6 I! doese whack your windshield, etc
Intl:
= Put the new mirror an by plaeing the naw miror below the
mounting Mature and popping the mirtor upwards and forwards
Into ple. Ono i's ined up, qlve it fm whack with your
hand sad it will pop on
«= Reconnect wiring and reinstall escla and sun visors. Note that
the sheet matals screws are easy to overlighten, whit wll
biow out the plastic mounting poins.
CHASSIS AND BODY
INTERIOR MIRROR (36 MODELS)
Service repair no - 76.10.51 - Manual
Service repair no = 76.10.54 - Auto dimming
Romove
NOTE: To remove manual mirrer, fallow
Ly test ony
4. Remava headlining front pocket
2. Release left hand sun viser from ep and move
aside.
Release sun visor clip screw cover.
|. Remave clip securing screw and remove cp,
5. Remave 2 serews securing sunroof ECU ant
move ECU aside,
8. Locate mirror multilug, remove efp-and
disconnect mutipug
7. Remove tape securing harness (behind
headlining).
Release miror from sereen by applying sharp
downward pressure to the base,
CAUTION: Do not use tapis to assist
removal. Mirror base shauld be moved in
direction of arrow, parallel ta windscreen,
9. Release hamess trom bohind headlining and
remove rier,