Professional Documents
Culture Documents
Error Code E1 High Pressure protect Explanation R Y G 1 Notes Explanation It is a sensor put aside the exhaust pipe.Once the pressure of exhaust pipe surpass 3.15Mpa, the airconditioning system will stop working. Sensor on the indoor unit dects the evaporator temperature continuously, once the temperature is lower than some point for certain time, it will turn off the system to avoid freezing the indoorunit. For system with low pressure sensor(locating aside the inspiration pipe), once the pipe's pressure is lower than 0.15Mpa, the system will stop working. 6 sec Pause before Flash Sequence Once the exhaust temperature of the compressor is higher than regulated, the system will be turned off automatically.
E4
Compressor Discharge protect low pressure over current protect indoor-outdoor communication Error
E5
Once the system current is higher than regulated,the system stops. Bad communication between indoor and outdoor units.
E6
E7 Mode conflict
For multi split airconditioners,when one of the indoors is working for cooling(dehumidifying),other indoor unit can no work for heating. While heating, indoor tube temperature sensor will detec While heating, the indoor fan will work several minutes later than the compressor so that the airflow comes out the airconditioner will not be too cold. For invertor system, the frequecy will lower down when the voltage drop sharply, so that the current can keep stable.
E8 E9
8 9
E0
10
H6
11
F1
F2
Indoor evaporator sensor open/short Outdoor temp sensor open/short Outdoor evaporator sensor open/short Outdoor sensor open/short
F3
F4
F5
F6 Cooling Overload
For invertor, while cooling, the outdoor tube temperature sensor detect the tempearture continuously, and will low the working frequency if the tube temperature is higher than some point for certain time. For invertors only.After a period of cooling, the system will work in higher frequecy for a period. For invertors only. Lower the freqecy, reduce the load if the current is higher than standard. For invertors only. Lower frequecny, if exhaust temperature is higher than standard.
F7
Unused
F8
Current Overlaod
F9
Unused Unused Defrost Static duct clean protect compressor overload protect
F0 H1
10 1 In heating condition, defrosting auotmatically and keep the heat exchange efficeincy.
H2
H3
Compressor stop working when the compressor temperature is higher than regulated. While cooling, system stops if the outdoor tube temperature is higher than a certain point for certain time. While heating, system stops if the indoor tube temperature is higher than a certain point for certain time. For invertors only.
H4 System Abnormal
H5 H6
Mode Protect
Unused
H7 H8
Synchronize fail
For system with water pump,such as cassette airconditiners, the system stop working when the water level surpassed regulated level.
H9 HO
9 10 For invertors only. While heating, lower the frequency if the indoor tube temperature is higher than standard. For invertors only.While cooling, lower the frequency if the outdoor tube temperatuer is higher than standard. For invertors only. While cooling, lower frequency if the indoor tube tempearture is lower than standard.
FA
FH
Freeze Protect
12201 N.W. 107 th Ave. Miami, Fl 33178 toll free: fax: (866) 591-9898 (305) 500-9896